Application of Modified Sand High-speed Filtration Technology to Reclaimed Wastewater Reuse

Ren-yong JIA,Li-ping SUN,Zhao-tao QI,Jian-bo LU,Xue-song YI

DOI: https://doi.org/10.3321/j.issn:1000-4602.2009.03.004

2009-01-01

Abstract:SJ material gained from industrial waste was applied to modify quartz sand filter media.The physical and chemical properties of the modified sand were determined,being better than those of natural quartz sand.Anthracite and the modified sand were used as filter media of high-speed filtration process to treat the secondary effluent from a WWTP.The average turbidity,COD,UV254,PO3-4-P of the filtration effluent are 1.23 NTU,27.4 mg/L,0.133 5 cm-1 and 0.42 mg/L respectively.The removal rates of pollutants by anthracite and the modified sand are higher than those by anthracite and natural quartz sand.The effluent quality meets the requirement of Reuse of Urban Recycling Water-Water Quality Standard for Urban Miscellaneous Water Consumption(GB/T 18920-2002).The initial filtration rate of high-speed filtration process should be the maximum filtration rate under natural conditions,and the causation of filtration rate decay is proved to be the reduction of the effective filtration area caused by the accumulation of pollutants and the separation of dissolved gas by filter vacuum.