Establishment and differential performance of hyperthermophilic microbial community during anaerobic self-degradation of waste activated sludge
Li-Jie Wu,Xiao-Xiao Li,Zhi-Feng Qin,Fan Yang,Quan Zhou,Rui-Peng Ren,Yong-Kang Lyu
DOI: https://doi.org/10.1016/j.envres.2020.110035
IF: 8.3
2020-12-01
Environmental Research
Abstract:<p>Hyperthermophilic anaerobic digestion, especially at 70 <sup>o</sup>C, has drawn wide attention. In order to acquire the inoculum and digestion characteristics, batch acclimation and continuous operation experiments were conducted under hyperthermophilic (70 <sup>o</sup>C), thermophilic (55 <sup>o</sup>C) and mesophilic (35 <sup>o</sup>C) conditions, respectively. Archaea at each temperature was successfully enriched from the sole-source waste activated sludge (WAS). Hyperthermophilic digestion achieved higher archaea diversity, close to the Shannon index 2.23 for the thermophilic digestion, but the population were not improved, at a 16S rRNA genes 5.99×10<sup>5</sup> copies mL<sup>-1</sup>. Hydrogenotrophic methanogens, <em>Methanospirillum</em> and <em>Methanothermobacter</em>, dominated in the hyperthermophilic digester, accounting for 27.15%, while the primary phylum <em>Firmicutes</em> was promoted to 36.31%, with the proteolytic genus <em>Coprothermobacter</em> in <em>Firmicutes</em> at 19.50%. Refractory organic fractions were converted more with a higher digestion temperature, which was demonstrated by the fact that the COD/VS increased to 5.8, 5.2 and 4.2 at 70 <sup>o</sup>C, 55 <sup>o</sup>C and 35 <sup>o</sup>C, respectively, at the end of batch acclimation. In addition, the most solubilization for the dominant fraction protein in the WAS occurred at 70 <sup>o</sup>C as well. Similar hydrolysis ratio, over 10%, and specific hydrolysis rate, around 0.025 g COD (g VSS·d)<sup>-1</sup>, were achieved at 70 <sup>o</sup>C and 55 <sup>o</sup>C. The higher hydrolysis for hyperthermophilic digestion even resulted in a higher methane yield than that for the mesophilic digestion. Nevertheless, contrary to higher hydrolysis, methanogenesis limited hyperthermophilic digestion in WAS degradation, with an ultimate methane yield 71.2 mL g<sup>-1</sup> VS<sub>added</sub>, despite an almost complete VFA conversion through the continuous operation.</p>
environmental sciences,public, environmental & occupational health