Abstract:The effect of the H2SO4 concentration in the hydrolysis of sunflower‐stalk waste, at 95ºC and using a liquid/solid relation of 20, was studied. In a later stage, the hydrolysates were fermented at different temperatures with the aim of ethanol and xylitol production. A total conversion of the hemicellulose at the acid concentration of 0.5 mol/L, was achieved; whereas an acid concentration of 2.5 mol/L was needed to reach the maximum value in the conversion of the cellulose fraction. The analysis of the hydrolysis kinetics has enabled to determine the apparent reaction order, which was 1.3. The hydrolysates from hydrolysis process with H2SO4 0.5 mol/L, once detoxified, were fermented at pH 5.5, temperatures 30, 40 and 50ºC with the yeast Hansenula polymorpha (ATCC 34438), resulting a sequential uptake of sugars. In relation to ethanol and xylitol yields, the best results were observed at 50°C (YEo = 0.11 g/g; YXy/sO = 0.12 g/g). Instantaneous xylitol yields were higher than in ethanol, at the three temperatures essayed. Different phenolic compounds were analysed in the hydrolysates; hydroxytyrosol was the most abundant (3.79 mg/L). The recovery of these compounds entails the elimination of inhibitors in the fermentation process and the production of high value‐added antioxidant products.This article is protected by copyright. All rights reserved

Production of Lactic Acid from C6-polyols by Alkaline Hydrothermal Reactions

Production of Lactic Acid from Polyols and Aldoses by Hydrothermal Reactions

Highly efficient production of L-lactic acid from xylose by newly isolated Bacillus coagulans C106.

Production of Lactic Acid from Glucose by Alkaline Hydrothermal Reaction

High-level Production of Poly (Β-L-malic Acid) with a New Isolated Aureobasidium Pullulans Strain

Formation of lactic acid from glycolaldehyde by alkaline hydrothermal reaction.

Conversion of Acid Hydrolysate of Oil Palm Empty Fruit Bunch to L-lactic Acid by Newly Isolated Bacillus Coagulans JI12

Simultaneous Detoxification, Saccharification and Co-Fermentation of Oil Palm Empty Fruit Bunch Hydrolysate for L-Lactic Acid Production by Bacillus Coagulans Ji12

Hydrothermal Conversion of Carbohydrates into Lactic Acid with Alkaline Catalysts

Production of Formic Acid and Acetic Acid by Hydrothermal Oxidation of Alkali Lignin

Efficient Production of L -Lactic Acid by Newly Isolated Thermophilic Bacillus Coagulans WCP10-4 with High Glucose Tolerance

Conversion Of Glycerin Into Lactic Acid By Alkaline Hydrothermal Reaction

Improvement of lactic acid production from cellulose with the addition of Zn/Ni/C under alkaline hydrothermal conditions

Alkaline hydrothermal conversion of glycerin into lactic acid

Fermentative production of L: -(+)-lactic acid by an alkaliphilic marine microorganism

Hydrothermal conversion of carbohydrate biomass to lactic acid

Biotechnological and in situ food production of polyols by lactic acid bacteria

Production of bioalcohols and antioxidant compounds by acid hydrolysis of lignocellulosic wastes and fermentation of hydrolysates with Hansenula polymorpha

Perspectives of engineering lactic acid bacteria for biotechnological polyol production

Production of Acetic Acid from Carbohydrate Biomass by Two-Step Reaction with Alkaline Hydrothermal Reaction and Wet Oxidation

Glycol Production from Sorbitol Hydrogenolysis over Hydrothermally Stable Ni Catalysts and the Mechanistic Study