Abstract:The rheological properties of warm-mix recycled asphalt binders are critical to enhancing design quality and interpreting the performance mechanisms of the corresponding mixtures. This study investigated the rheological behavior of warm-mix recycled asphalt binders with high percentages of RAP binder. The effects of two warm-mix additives [wax-based Sasobit (S) and surfactant-based Evotherm-M1 (E)], a rejuvenating aging [ZGSB (Z)], four RAP binder contents (0%, 30%, 50% and 70%), and three aging states (unaged, short-term aged and long-term aged) were evaluated in detail using the dynamic shear rheometer (DSR), bending beam rheometer (BBR) and Brookfield rotational viscometer tests as well as conventional performance tests over the whole range of temperatures. The results showed that the rejuvenating agent Z effectively alleviated the aging effect of the RAP binder; however, it could hardly eliminate entirely this negative impact, especially at higher RAP binder contents. The addition of S remarkably lowered the apparent viscosity of the warm-mix recycled binders by up to 35.0%, whereas E had little influence on the binder viscosity due to its surfactant nature. Besides, S performed much better in improving rutting resistance (with the increase of up to 411.3% in |G*|/sinδ) than E, while E exhibited superior fatigue performance (with the reduction of up to 42.3% in |G*|·sinδ) to that of S. In terms of the thermal cracking resistance, E had very slight influence and S even yielded an adverse impact (with the increase of up to 70.2% in Sa and the decrease of up to 34.1% in m-value). Further, S broadened the ranges of pavement service temperatures by about 12 °C, whereas E almost did not change the PG grades of the binders. Finally, regarding the characteristics of viscoelastic master curves, S considerably improved the dynamic modulus and lowered the phase angle of the binders over a wide range of frequencies and temperatures but led to the failure of the time-temperature superposition principle due to its thermorheologically complex nature. Nevertheless, in this regard, the effect of E was found very mild.

New Indexes for High-Temperature Performance Evaluation of Asphalt Binder:Visco-Consistency

Effects of Asphalt Binder Type on Mixing Flowability and Workability Index of Asphalt Mixtures

Research on High- and Low-Temperature Rheological Properties of High-Viscosity Modified Asphalt Binder

Nonlinear Viscoelastoplastic Kinetics for High-Temperature Performance of Modified Asphalt Binders

Nonlinear Viscoelasticity and Viscoplasticity Characteristics of Virgin and Modified Asphalt Binders

Investigation of Viscoelastic Properties of Polymer-Modified Asphalt at Low Temperature Based on Gray Relational Analysis

Analysis of Different Indices for High- and Low-Temperature Properties of Asphalt Binder

New Index Used to Evaluate the High-Temperature and Low-Temperature Performance of Asphalt

A New Short-Term Aging Model for Asphalt Binders Based on Rheological Activation Energy

Towards an Index of Asphalt Mixture Homogeneity

Study of the Viscoelasticity for Fibrous High ViscoelasticAsphalt Sand

Evaluation of Test Methods for Fracture Resistance of High Modulus Asphalt Binders from Rheological and Mechanical Perspectives

Dynamic Viscoelastic Property of Hard-Grade Asphalt Mixture

The Research on the Index of High Temperature Performance of Asphalt Mixture in Airfield

Investigation into Rheological Behavior of Warm-Mix Recycled Asphalt Binders with High Percentages of RAP Binder

High-Temperature Performance of Polymer-Modified Asphalt Mixes: Preliminary Evaluation of the Usefulness of Standard Technical Index in Polymer-Modified Asphalt

Predicting the Low-Temperature Performance of Asphalt Binder Based on Rheological Model

Research on Fracture Performance Test and Physical Hardening Tendency of Asphalt Binder

Analysis of Coupling Effect and Heavy Load of High-Temperature Stability of Asphalt Mixture

Study on Viscoelastic Properties of Various Fiber-Reinforced Asphalt Binders

Low-temperature evaluation index of rubber asphalt