Abstract:The automotive electronic throttle (AET) control system has been widely applied in modern automotive engines, and accurate control of AET can improve engine performance as well as reduce pollution emissions. However, the noise in the sensor circuit and the variation in automotive driving conditions seriously affect the control performance of the AET system, making controller designing challenging. This paper proposes a self-tuning backstepping control with a Kalman-like filter (SBCKLF) strategy. First, the noise affecting the position sensor measurement is verified to be non-Gaussian by acquiring and processing the noise signal. To eliminate its influence on control precision, a Kalman-like filter is introduced to estimate the real position of the valve. Then, a self-tuning backstepping controller is designed to automatically adapt to the variation in vehicle driving conditions. A self-tuning algorithm based on fuzzy control is used to tune the parameters of the backstepping controller online, so as to optimize the controller performance. Finally, an experimental platform based on dSPACE for the AET control system is built to perform the controller comprehensive test in a real-time environment. Experimental results and performance analysis demonstrate the effectiveness of the proposed SBCKLF strategy. Compared to the best results of other methods, the proposed method reduces the maximum and root mean square tracking errors by 21.65% and the average error by 12.89%. The steady-state and tracking error bounds are controlled to 0.9° and 2.3°, respectively. It also shows that the SBCKLF strategy has the strongest robustness as well as the best response speed.

A Research on the Control Algorithm and Its HIL Simulation of Automotive ASR Systems

Emergency Braking Control Strategy for High Speed Electric Drive Tracked Vehicle

Simulation of Brake Pressure Control Mode of ASR System

Design of an Asr System of an Electric Passenger Car

Modeling and Adaptive Control of the Electro-Hydraulic Braking System of Low-Floor Vehicle

Vehicle Adaptive Cruise Control Design with Optimal Switching Between Throttle and Brake

Co-Simulation On Performance Evaluation Of A New Electronic Control Hydraulic Braking System

Intelligent Momentary Assisted Control for Autonomous Emergency Braking

Research on the steering antilock braking control system for the vehicles

Hydraulic Pressure Control And Parameter Optimization Of Brake-By-Wire System Based On Driver-Automation Cooperative Driving

Integrated DYC and ASR Mixed Control of Distributed Drive Electric Vehicle Using Co-Simulation Methodology

Application of Integrated Simulation System for Air-Brake TCS Control Development

Research on control strategy of electric-hydraulic hybrid anti-lock braking system of an electric passenger car

Discrete fuzzy adaptive PID control algorithm for automotive anti-lock braking system

Tire slip control based on integrated-electro-hydraulic braking system

A Model Predictive Control Approach for Electro-hydraulic Braking by Wire

Optimal control for anti-lock braking system: Output feedback adaptive controller design and processor in the loop validation test

Design and experimental validation of control algorithm for vehicle hydraulic active stabilizer bar system

Yaw Stability Control Based On A Novel Electronic Hydraulic Braking System

A Modeling and Control Algorithm for a Commercial Vehicle Electronic Brake System Based on Vertical Load Estimation

Self-Tuning Backstepping Control with Kalman-like Filter for High-Precision Control of Automotive Electronic Throttle