Abstract:To reduce the cost of silica-based materials, an agricultural waste, rice husk (RH), was transformed into higher valuable products such as MCM-41 and organo-functionalized MCM-41 in the frame of circular economy. RH is the biomass waste containing the highest amount of silica (214 g kg−1). Direct calcination of RH led to silica with low surface area (10 m2 g−1), which could not be transformed into MCM-41. After optimization, silica of 310 m2 g−1 was produced by washing RH with HCl 0.1 mol L−1 at 25 °C and calcination at 600 °C. Such silica was successfully transformed in one-step synthesis at 115 °C for 24 h into highly ordered MCM-41 (800 m2 g−1) and organo-functionalized MCM-41 (510 – 720 m2 g−1) including aminopropyl and amide derivatives of amino acids (Leucine, Serine and Tyrosine). The corresponding organo-triethoxysilanes alone or in mixture were directly added in the synthesis with silica from RH, octadecyltrimethylammonium and NaOH solution. Surfactant removal was successfully performed with EtOH/NH4NO3 solution at 60 °C. The mesopore diameter of the materials were homogeneous and varied from 3.8 to 4.2 nm depending on the organic functions. Thanks to the use of the concept of pseudomorphic transformation, the particle size of the materials ranged from 1 to 100 m. As proof of concept, the 50-100 m fraction (30% of the volume) was successfully used to fill columns to run size exclusion chromatography for protein separation. The largest protein, Bovine Serum Albumine (BSA) was excluded from all materials as its kinetic diameter (d = 7.2 nm) was larger than the mesopore diameter. The smallest proteins: carbonic anhydrase (d = 4.2 nm), myoglobin (d = 3.8 nm) and lysozyme (d = 3.4 nm) were retained by the materials. Their retention factor increased as the kinetic diameter decreased, as the mesopore diameter decreased and as the hydrophobicity of the materials increased. The best separation of proteins was obtained with MCM-41 functionalized with both Leucine and Serine amide derivatives.

A Novel Mesoporous Lignin/silica Hybrid from Rice Husk Produced by a Sol–gel Method

Poly(L-Lactic Acid)/Sio2 Nanocomposites Via in Situ Melt Polycondensation of L-Lactic Acid in the Presence of Acidic Silica Sol: Preparation and Characterization

Preparation of Water-Insoluble Lignin Nanoparticles by Deep Eutectic Solvent and Its Application As a Versatile and Biocompatible Support for the Immobilization of Α-Amylase.

Peculiarities of Synthesis and Properties of Lignin–Silica Nanocomposites Prepared by Sol-Gel Method

Controllable conversion of biomass to lignin-silica hybrid nanoparticles: High-performance renewable dual-phase fillers

Fabrication of mesoporous silica nanoparticles by sol gel method followed various hydrothermal temperature

Synthesis and structural characterization of lignin/silica hybrid nanoparticles functionalized with sulfonic acid-terminated polyamidoamine

Preparation of highly dispersed nanosilica from rice husk by aprecipitation method combined with high pressure homogenization

Improvement of the characteristics of silica particles extracted from rice husks using chemical-physical method

Facile adjusting the concentration of siliceous seed to obtain different HZSM-5 zeolite catalysts for effective catalytic depolymerization reaction of lignin

Mechano-chemical conversion of rice husk ash and gasifier-derived rice husk ash into porous silicon

Mesoporous Silicas Synthesis and Application for Lignin Peroxidase Immobilization by Covalent Binding Method

Grafting of lignin onto nanostructured silica SBA-15: preparation and characterization

Simultaneous Synthesis of Silica Polymorphs and Activated Carbon from Rice Husk

Study on lignin amination for lignin/SiO2 nano-hybrids towards sustainable natural rubber composites

Synthesis and characterization of mesoporous silica nanoparticles (MSNp) MCM 41 from natural waste rice husk

Mesoporous Silica with an Alveolar Construction Obtained by Eco-Friendly Treatment of Rice Husks

Morphology, Extraction Yield, and Properties of Biogenic Silica Nanoparticles from Indonesian Rice Husk as Influenced by Solvent Type and Aging Time

Enhancement of rice husks saccharification through hydrolase preparation assisted by lytic polysaccharide monooxygenase

Chemical and structural properties of silica obtained from rice husk and its potential as a catalytic support

Direct pseudomorphic transformation of silica from rice husk into organo-functionalized MCM-41