Abstract:As a medicinal plant with high economic value, the green and efficient separation of the main components (essential oil (EO) and flavonoids) from Thymus vulgaris L. can enhance its application prospects. The present study developed a polyethylene glycol-ultrasonic pretreatment followed by microwave hydrodistillation and extraction (PEG-U-MHDE) technique to distill EO and extract flavonoids simultaneously. The parameters involved in the PEG-ultrasonic pretreatment and microwave irradiation processes were investigated using single factor and BBD experiments, from which 25 % PEG200/400/600 (1:1:1, v/v/v) was found to have the highest extraction ability. Under the optimal conditions, the yield of EO, apigenin, and baicalein was 3.72 f 0.15 mu L/g, 0.76 f 0.03 mg/g, and 0.96 f 0.03 mg/g, respectively. The PEG-U-MHDE showed good stability, recovery, and repeatability for apigenin and baicalein. In addition, the separation efficiency of EO, apigenin, and baicalein obtained by PEG-U-MHDE was 0.19 mu L/g/min, 37.85 mu g/g/min, and 48.03 mu g/g/min, respectively, and the EO contained 81.77 % oxygenated compounds, which were higher than other reference methods. The inhibition rate of EO (concentration of 0.5 mu L/mL) against the agricultural pathogenic fungus (Fusarium graminearum) was 36.65 f 1.28 %, which was speculated to be closely related to its main oxygenated compounds (thymol and carvacrol). In general, PEG-U-MHDE has the advantages of short time and high efficiency, and can realize the simultaneous separation of volatile EO and non-volatile components, which provides a theoretical basis for the comprehensive utilization of natural medicinal plants and crops.

New extraction process of mogrosides

Development of a process for separation of mogroside V from Siraitia grosvenorii by macroporous resins.

Research on technological process of two-pot countercurrent extraction of hydroxysafflor yellow A

Methodology of enzymic hydrolysis of fifty percent mogroside V

[Study on Extraction Technology for Extract and Flavonoids in Chrysanthemum Morifolium by Orthogonal Design].

Process of Extracting Polysaccharides from Smilax Glabra Roxb. by Microwave -Assisted Method

Technique Optimization for Extracting Total Flavonoids in Anoectochilus Roxburghii by Ultrasonic-Assisted Solvent

Rapid Identification and Quantification of Five Major Mogrosides in Siraitia Grosvenorii (Luo-Han-guo) by High Performance Liquid Chromatography–triple Quadrupole Linear Ion Trap Tandem Mass Spectrometry Combined with Microwave-Assisted Extraction

RSM for Optimize Extraction Process of Wild Chrysanthemum Granules

Optimization on Microwave-assisted Extraction of Essential Oil from Cyperus rotundus L.

Optimization of the Microwave-Assisted Extraction Condition of Agrocybe Aegeritaw RN

An enhanced extraction and enrichment phytochemicals from Rosa roxburghii Tratt leaves with ultrasound-assist CO2-based switchable-solvent and extraction mechanism study

A Novel Strategy for Obtaining Essential Oil and Flavonoids from Thymus Vulgaris L. Using Polyethylene Glycol-Ultrasonic Pretreatment Followed by Microwave Hydrodistillation and Extraction

Optimization of Ultrasonic Extraction Process of Total Flavonoids from Mulberry Leaves by Orthogonal Experiment

Development of New Multi-Glycosylation Routes to Facilitate the Biosynthesis of Sweetener Mogrosides from Bitter Immature Siraitia Grosvenorii Using Engineered Escherichia coli

Extraction process optimization of essential oil from Mellissa officinalis L. using a new ultrasound-microwave hybrid-assisted Clevenger hydrodistillation

STUDY ON EXTRATION PROCESS OF PROPOUS BY MICROWAVE AND ULTRASONIC

Experimental Research on Extraction and Purification of Ramulus mori Polysaccharide

Optimization of the ultrasonic extraction technique of glycyrrhizic acid by using response surface methodology

Method for preparing high-purity Momordia grosvenori aglycone from Momordia grosvenori

Extraction of Chromone from Saposhnikovia Divaricata by Ultrasonic Wave