Low NO_x combustion technologies

徐向乾,巩志强,姜波,路春美

2007-01-01

Abstract:The main measures to reduce NOx emission in a boiler combustion and the flue gas denitrification principles at home and abroad are introduced.It has great significance to the environmental protection to develop the low NOx combustion technologies.

What problem does this paper attempt to address?

TECHNOLOGIES OF NO_X EMISSION CONTROL FOR COAL-FIRED POWER PLANTS

Zhou Tao,Liu Shaoguang,Wu Jinming

2008-01-01

Environmental engineering

Abstract:NO_X is one of the main pollutants in the atmosphere.It has made big hazard to the environment and the human body.Coal-fired power plant is one of the main sources emitting NO_X.Now how to eliminate NO_X from coal-fired power plant effectively is to be a priority and a difficulty.The mechanism of NO_X formation during the process of coal combustion is discussed.At the same time,it is introduced in detail the main methods and technical features of low NO_X combustion technology and flue gas denitration technology.
Low NOx Combustion Technology for Coal-fired Boiler and Experimental Research

魏恩宗,骆仲泱,岑可法,闫志勇,张惠娟

DOI: https://doi.org/10.3969/j.issn.1005-006x.2001.06.016

2001-01-01

Abstract:The mechanism of NOx formation in coal burning, the common NOx emission control methods and the principle of air staged combustion are analyzed. Technical reformation in a plant is conducted for experimental research, and actual effects to reduce NOx emission for coal-fired boiler adopting air staged combustion technology and influence factors are found by experiment.
On Retrofitting Coal-fired Boilers with Capacity of 100 MWe～200 MWe to Reduce NOx Emission

ZHANG Hai,XU Xiu-qing,ZENG Rui-liang,YUE Guang-xi,LU Jun-fu,LIU Qing

DOI: https://doi.org/10.3969/j.issn.1672-4763.2005.05.013

2005-01-01

Abstract:A general introduction on NO_(x)emission from the 100 MWe~200 MWe coal-fired boilers in China and the principles of low NO_(x) emission combustion was given.The available de-NO_(x) techniques to retrofit these boilers are discussed,with respective to the commonly used tangential-firing and wall-firing combustion systems respectively.The practices of retrofitting boilers on low emission by Tsinghua University were introduced.The results indicated that it is possible to apply the cost-effective retrofit in combustion system to achieve a rather stringent NO_(x) regulation.
Study on Low NOx Optimimal Operation of a Tangentially Fired Boiler under Variable Parameters

秦岭,杨卫娟,周志军,黄镇宇,刘建忠,周俊虎,岑可法

DOI: https://doi.org/10.3969/j.issn.1005-006x.2006.04.003

2006-01-01

Abstract:The NOx of coal burning boiler is main for fuel type, and overwhelming majority NOx is created in the position of inflamers. It will make great function for control NOx if we can control the atmosphere of this position. It takes a 410t/h boiler for example, and tell us for the existence boiler, the change of air and coal distributing can ameliorate the boiler performance and lowering NOx exhausting deal.
Study on Low NOx Combustion Technology and Technical Reform of a 420 T/h Power Plant Boiler

周志军,陆智,刘茂省,邵杰,刘建忠,周俊虎,岑可法

DOI: https://doi.org/10.3969/j.issn.1004-3950.2008.04.011

2008-01-01

Energy Engineering

Abstract:Experimental research on four coals of a 420 t/h unit boiler was carried out by thermal balance and sedimentation furnace.The combustion features of coals and the NOx emission of coals were analyzed.The contrast analysis was conducted between several low NOxcombustion technologies,and the current burner was diagnosed.The boiler reforming in the scheme of SOFA can meet the NOx emission standard of power plant.
NOx Emission and Its Control in Utility Coal-fired Boilers in China

张海,吕俊复,徐秀清,曾瑞良,岳光溪

DOI: https://doi.org/10.3321/j.issn:1000-6761.2005.01.026

2005-01-01

Abstract:The current situation of NOx emission of utility boilers in China is being analyzed. The feasibility of lowering NOx emission by adopting a firing that combines low NOx burners (LNB) with staged combustion favorable for air/fuel reducing NOx emission is discussed. An introduction to the structure, principle and industrial application of the Multi-Enriched LNB (MELNB), recently developed by Tsinghua University is being presented to exemplify the design principle of LNB. It is emphasized that the control of NOx emission should be considered in a systematic manner. In addition, the effects of tertiary air on NOx emission are analyzed. Results indicate that the existing arrangement of tertiary air is unfavorable for the reduction of NOx emission. Some suggestions concerning research on lowering NOx emission of utility boilers are given.
Technique of NOx Pollution Control for Flue Gas

王海强,吴忠标

DOI: https://doi.org/10.3969/j.issn.1004-3950.2004.03.009

2004-01-01

Energy Engineering

Abstract:Nitric oxides (NO_x) are major air pollutants, as well as a difficult problem in air pollution control. This paper mainly introduces some methods in the reduction of NO_x for commercial use or in research stage, including selective catalytic and non-catalytic reduction, catalytic decomposition, electron beam treatment, aqueous absorption, adsorption treatment and biological treatment. The current application and prospective of these methods are reviewed, and these characteristics and existing problems are analyzed. The research progress and trend in the reduction of NO_x are discussed.
Research development of pulverized coal flameless combustion technology and low NOx emission

Zhijun ZHOU,Ying ZHONG,Bin QIAN,Ben LIU,Junhu ZHOU

DOI: https://doi.org/10.3969/j.issn.1002-3364.2015.02.001

2015-01-01

Abstract:With such features as simple equipment,uniform combustion temperature,high﹣efficiency and ex﹣tremely low emissions,flameless combustion technology gains wide attentions in the international combus﹣tion field,and is praised as one of the combustion methods with the most development potentiality in the 21st century.The advantages,formation mechanism and implementation models are analyzed.The status quo and development tendency of pulverized coal flameless combustion and NOx emission reduction at home and abroad are summarized from three items including combustion characteristics and emission characteris﹣tics,numerical simulation,and new combustion modes.In addition,research content and significance of pul﹣verized coal flameless combustion technology in a deepen way are discussed.
The Large Capacity Pulverized Coal Fired Utility Boiler and the Low Nox Combustion Technology Developments in China in Response to Environmental Challenges

Hao Zhou,Guiyuan Mo,Kefa Cen

DOI: https://doi.org/10.1115/power2011-55473

2012-01-01

Abstract:Large capacity pulverized coal fired utility boiler technology is in quick developments in China, hundreds of super critical boilers have been constructed in the last several years which can achieve high efficiency and low pollutants emissions. The different types of super critical boilers are introduced in this paper, they include the single-furnace with double fireball corner fired furnace, the wall fired furnace and the tower-type furnace. The low NOx combustion technologies have been widely used to face the environmental challenges. The low NOx technologies employed in pulverized-coal boilers consist of the combustion modification and post-combustion technology. The low NOx combustion modification technology includes the low NOx burner, close coupled over fire air (CCOFA) and separated over fire air (SOFA). The post-combustion technology consists of selective non-catalytic reduction (SNCR) and selective catalytic reduction (SCR) technologies. Zhejiang University develops integrated low NOx technology, including the low NOx combustion system, SNCR system and SCR system. This integrated technology can reduce the NOx emissions to be lower than 50 mg/Nm(3).
Technology Status and Analysis on Fired Flue Gas Denitrification

GAO Lin,LI Hui,SHAN Li-yuan,HUANG Jia,YU You-hai,MIN Yong-gang

DOI: https://doi.org/10.3969/j.issn.1005-9954.2017.03.004

2017-01-01

Chemical engineering

Abstract:The effect of nitrogen oxides (NOx) on environment and human activities became worse,so how to control the generation of NOx in flue gas and reduce its emissions became the focus of people.The principles and characteristics of various technologies and existing problems were illustrated,in addition,the potential research direction and prospects to control NOx emissions were put forward.
Application of Ultra-Low NOx Emission Control for CFB Boilers Based on Theoretical Analysis and Industrial Practices

Xiwei Ke,Runxia Cai,Man Zhang,Miao,Junfu Lyu,Hairui Yang

DOI: https://doi.org/10.1016/j.fuproc.2018.10.001

IF: 8.129

2018-01-01

Fuel Processing Technology

Abstract:Circulating fluidized bed (CFB) boilers face sever challenges in China due to the new ultra-low emission rules, more specifically, the NOx emission must be lower than 50 mg/m(3). In this paper, NOx evolution inside CFB furnaces and the gas-solid flow characteristics were reviewed. It is found that NOx emission can be reduced through re-specification of fluidization state, namely, improving the bed quality. A low NOx emission (de-NOx) technology applied to CFB boilers was thus proposed. The keys of the technology are decreasing the average size of bed materials, limestone included, and increasing the solid circulating rate by improving the performance of circulating loop including improving cyclone efficiency, controlling slag discharge, etc. Some industrial practices showed that when the average size of bed inventories is markedly reduced, and when using ultrafine limestone, NOx emission can be significantly decreased without undermining high efficiency desulfurization. This paper provides a new solution to low-cost pollution control of CFB boilers.
Low NO_x Emission Characteristic of Low Energy Consumption CFB Boilers

Li Jingji,Yang Hairui,Lü Junfu,Zhang Jianchun,Cao Peiqing,Zhao Yonggang,Bai Yang

DOI: https://doi.org/10.11715/rskxjs201304002

2013-01-01

Abstract:Due to the new NOx national emission regulation,it is more and more significant to reduce the NOx emission.By reconstructing the fluidization state of gas-solid flow in the CFB furnace,the low energy consumption(LEC)CFB boiler was developed and popularized so that the problems of high auxiliary power,serious wear of water-wall and low combustion efficiency could be solved.However,it is still uncertain to evaluate the influence of the technology on NOx emission.Therefore,the NOxgeneration theory and the main principle of LEC CFB are firstly introduced based on the existing theory and the experimental results.Viewing from the factors of bed temperature and oxidizing-reducing atmosphere,it is demonstrated that the LEC CFB technology has a potential advantage on NOx emission.
RESEARCH ADVANCEMENT AND FUTURE PROSPECT OF LOW Nox BURNERS FOR PULVERIZED COAL

周俊虎,赵玉晓,刘建忠,杨卫娟,周志军,岑可法

DOI: https://doi.org/10.3969/j.issn.1002-3364.2005.08.001

2005-01-01

Abstract:Directing against increasingly strict emission standard, the technical features, application status quo, as well as advatanges and disadvantages of comparatively advanced low NO_x burners for pulverized coal at home and abroad have been presented from two aspects: straightflow buning and swirl burning. And thereby further researching direction in the future has been put forward, to deve-lop low NO_x burners suitable for national conditions of our country.
Emission on NOx in High Temperature Combustion with Low Oxygen Concentration

祁海鹰,李宇红,由长福,苑皎,徐旭常

DOI: https://doi.org/10.3321/j.issn:1006-8740.2002.01.005

2002-01-01

Abstract:The development of the high temperature air combustion technology is based on the principle of high temperature combustion with low oxygen concentration. In this case the emission of NOx is reduced greatly. In order to better understand the mechanism of this unconventional combustion phenomenon and formation of pollutants, the influence of oxygen concentration in combustion air on flame and NO emission features has been investigated numerically. The diffusion combustion model, thermal NO model and the turbulent N-S equations have been used in the calculation. Both the stable flame and low NO emission characteristics were predicted well. The calculated results agree with the experimental observation and can be used as fundamental data for developing the high temperature air combustion technology in China.
Generation,digestion and Control of N2O in Circulating Fluidized Bed Boiler Using Coal

WANG Qi-min,LI Yuan,YANG Hai-rui,LV Jun-fu

DOI: https://doi.org/10.3969/j.issn.1673-1603.2007.02.004

2007-01-01

Abstract:Except for advantages that combustion efficiency is similar to pulverized coal boiler,cheap desulfurization equipment,low operation cost,relative low NOX emission concentration,circulating fluidized bed boiler has a fatal weakness,namely,N2O emission concentration is higher than pulverized coal boiler.N2O not only has the greenhouse effect,but also can destroy strongly ozone in stratosphere,bring ozone hole,furthermore,it is super-stable in atmosphere.Summarizes the research fruit in recent years on the aspects of generation principle,digestion mechanism and reducing emission measures of N2O in circulating fluidized bed boiler,gives more reasonable explanation for some reducing emission measures,and analyzes the restriction condition for every reducing emission measure,so as to offer theoretical reference for N2O emission control in circulation fluidized bed boiler which is more suitable for fact.
Application of Air-staged and Low NOx Emission Combustion Technology in Plant Boiler

ZHOU Jun-hu,ZHAO Chen-jie,XU Jian-hua,ZHOU Zhi-jun,HUANG Zhen-yu,LIU Jian-zhong,CEN Ke-fa

DOI: https://doi.org/10.13334/j.0258-8013.pcsee.2010.23.010

2010-01-01

Abstract:An air-staged and low NOx emission combustion technology was studied with a SG–420/13.7–W756 boiler. Data about the effects of nitrogen oxide emissions were obtained. The influence of the technology on the efficiency of the boiler and the slagging condition was analyzed, and methods for slagging prevention, such as low NOx burner and air surrounding fuel technology were used to draw the main conclusions as follows: i) With the adjustment of the air proportion among different injectors, the nitrogen oxide emission of the boiler is reduced to 379mg/m3@6%O2 achieving a removal rate of 37.8%. ii) The efficiency of the boiler is increased by the operation with low oxygen concentration. iii) The air-staged and Low NOx Combustion does not bring about slagging problem.
Study on Nitrous Oxide Emission in Boiler Furnace

Zhong B. J.,Fu W. B.

DOI: https://doi.org/10.1007/s11630-997-0040-3

1997-01-01

Abstract:A theoretical investigation on a kinetic mechanism of nitrous oxide formation in flames with different fuels was carried out for purposes of minimizing the total NOx yield. The effect of fuel type and combustion condition on N2O emission is discussed. It is found that N2O constitutes a relatively small fraction of the total NOx formation, but it is of great importance to both NO formation and NO reduction from fuel nitrogen (Nf) and molecular nitrogen (N2).
Experiment and numerical study on combustion characteristics of low-nitrogen burners

Yi Liu,Youchang Zhao,Lin Zhang,Jiayong Wu,Jinjie Feng,Chengman Zhou,Yanru Shen,Xi Zhan,Kexin Dong,Qi Wang

DOI: https://doi.org/10.1016/j.fuel.2023.128814

IF: 7.4

2023-06-09

Fuel

Abstract:Low nitrogen combustion has always been an essential topic in energy conservation and environmental protection. This paper proposes a new type of low-nitrogen burner, which aims to optimize the burner structure and reduce NOx emission . Fuel and air staged combustion and central swirl technology are adopted in the burner to reduce local high-temperature areas and NOx generation. The effects of the new low-nitrogen burner's structural parameters and operating parameters on the temperature distribution, velocity distribution and NOx concentration distribution in the furnace are analyzed by cold state experiment and numerical simulation. The results show that: the cyclone blade deflection angle of 30 and the main combustion stage gas nozzle of 3 are the optimal structural parameters. The secondary combustion stage gas ratio of 0.1, the excess air coefficient of 1.05, and the air preheating temperature of 298 K are the optimal working condition parameters. At this moment, the furnace has the highest average temperature, the best combustion efficiency and the lowest NOx emission. These indicates that the novel low-nitrogen burner can be a suitable device for reducing NOx emission.

energy & fuels,engineering, chemical
Experimental Research on the Combustion and NO_x Generation Characteristics of Low Volatile Coal

ZHOU Zhijun,ZHOU Ning,CHEN Yaoji,ZHOU Junhu,LIU Jianzhong,CEN Kefa

2010-01-01

Abstract:Thermogravimetry analysis was used to study the combustion process of low volatile coals in order to ascertain the combustion characteristics of low volatile coals.The paper studied the NOx release characteristics of low volatile coals in a fixed-bed reactor systematic.Experimental results show that the ignition temperatures of low volatile coals are higher than the bituminous and lignite,low volatile coals have poor flammability,but the stable combustion and burn performance can still be.As the temperature increases,emission amount of NOx decreases.There is an optimum particle size for low-volatile coal,which has the minimum conversion rate of the NOx,and the optimum particle size varies with the different coal pulverized.When the oxygen concentration increases,the NOx conversion rate increased accordingly.The result coincide with the actual situation for boiler combustion,which has some guiding significance for controling the emission NOx in combustion process.
Low NO_x Combustion Tests on a 200MW Coal-Water Slurry Fired Boiler

Cen Ke-fa

2007-01-01

Abstract:Profound comparison combustion tests of low NO_x emission were conducted on a 200 MW coal-water slurry fired boiler,with uniform air allotment,staged allotment and also under reburning conditions.Test results show that NO_x emission is largest under uniform air allotting conditions,while recombustion and staged allotment of air can also effectively,but only to a certain degree,reduce NO_x emission.Under test conditions,it was found that denitrition rate is highest for the case of stage allotted air and CO emission deminishes considerably,both in case of reburning so for stage allotted air.

Low NO_x combustion technologies

TECHNOLOGIES OF NO_X EMISSION CONTROL FOR COAL-FIRED POWER PLANTS

Low NOx Combustion Technology for Coal-fired Boiler and Experimental Research

On Retrofitting Coal-fired Boilers with Capacity of 100 MWe～200 MWe to Reduce NOx Emission

Study on Low NOx Optimimal Operation of a Tangentially Fired Boiler under Variable Parameters

Study on Low NOx Combustion Technology and Technical Reform of a 420 T/h Power Plant Boiler

NOx Emission and Its Control in Utility Coal-fired Boilers in China

Technique of NOx Pollution Control for Flue Gas

Research development of pulverized coal flameless combustion technology and low NOx emission

The Large Capacity Pulverized Coal Fired Utility Boiler and the Low Nox Combustion Technology Developments in China in Response to Environmental Challenges

Technology Status and Analysis on Fired Flue Gas Denitrification

Application of Ultra-Low NOx Emission Control for CFB Boilers Based on Theoretical Analysis and Industrial Practices

Low NO_x Emission Characteristic of Low Energy Consumption CFB Boilers

RESEARCH ADVANCEMENT AND FUTURE PROSPECT OF LOW Nox BURNERS FOR PULVERIZED COAL

Emission on NOx in High Temperature Combustion with Low Oxygen Concentration

Generation,digestion and Control of N2O in Circulating Fluidized Bed Boiler Using Coal

Application of Air-staged and Low NOx Emission Combustion Technology in Plant Boiler

Study on Nitrous Oxide Emission in Boiler Furnace

Experiment and numerical study on combustion characteristics of low-nitrogen burners

Experimental Research on the Combustion and NO_x Generation Characteristics of Low Volatile Coal

Low NO_x Combustion Tests on a 200MW Coal-Water Slurry Fired Boiler