Abstract:Most of nitrogen emissions can be ascribed to agro-industrial activities. Since digestate produced by fermentation of agro-industrial residues can be difficult to dispose of due to its high ammonium content, advanced technical- and cost-effective technologies must be developed and applied in order to significantly reduce its impact on the environment. In this study, aerobic granules were successfully cultivated in a granular sludge sequencing batch reactor (GSBR) fed with the ammonium-rich (approx. 2500 mg L−1) effluent of a 3-stage anaerobic digester treating agro-industrial residues. The peculiar characteristics of such wastewater required a 2-step operating strategy aimed at the selection of nitrifying biomass (Step 1) and the formation of aerobic granular sludge (Step 2). During Step 1, nitrifying biomass selection was achieved by properly regulating the cycle length: N H 4 + - N removal rates progressively increased from 42 to 109 mgN L−1d−1, and a corresponding increase in N H 4 + - N specific removal rates from 8 to 24 mgN gVSS −1d−1 was also observed. During Step 2, the increase in selective pressures (i.e. minimum settling velocity and volumetric organic loading rate) led to the formation of compact (average diameter, 1.02 ± 0.43 mm) and well-settling granules (SVI5, 28.6 ± 3.8 mL gTSS −1), which were able to remove up to 89 ± 2% of organic matter (as COD), 79 ± 3% of N H 4 + - N and 59 ± 4% of nitrogen (as a sum of N H 4 + - N , N O 2 – - N and N O 3 – - N ). The 2-step operating strategy played a key role in biomass selection and subsequent granule formation and maintenance in the GSBR, and may be successfully adopted for the treatment of different ammonium-rich wastewaters.

Aerobic granulation with brewery wastewater in a sequencing batch reactor.

A Case for Aerobic Sludge Granulation: from Pilot to Full Scale

Rapid aerobic sludge granulation in an integrated oxidation ditch with two-zone clarifiers.

Formation of Aerobic Granular in Pilot-scale SBR for Real Wastewater Treatment

Cultivation and Granulation Process of Aerobic Granular Sludge Applied to Treat Municipal Wastewater

Aerobic Sludge Granulation in a Full-Scale Sequencing Batch Reactor

Cultivation of Aerobic Granular Sludge with A Mixed Wastewater Rich in Toxic Organics

Cultivation of Aerobic Granular Sludge Using Municipal Wastewater and Its Degradation Characteristics

Aerobic Granulation in a Sequencing Batch Reactor for the Treatment of Piggery Wastewater

Effect of COD/N ratio on cultivation of aerobic granular sludge in a pilot-scale sequencing batch reactor

Cultivation and Characteristics of Aerobic Granular Sludge in Sequencing Batch Reactor

Stability of aerobic granular sludge in a pilot scale sequencing batch reactor enhanced by granular particle size control

Performance of A Nitrifying Airlift Reactor Using Granular Sludge

Granulation of Activated Sludge in A Pilot-Scale Sequencing Batch Reactor for the Treatment of Low-Strength Municipal Wastewater

Rapid cultivation of aerobic granular sludge in a pilot scale sequencing batch reactor

On Cultural Condition of Aerobic Granular Sludge in Brewing Anaerobic Effluent

Aerobic granular sludge formation in a sequencing batch reactor treating agro-industrial digestate

Cultivation, Granulation and Characteristics of Anaerobic Ammonium-Oxidizing Sludge in Sequencing Batch Reactor

Granular Activated Carbon for Aerobic Sludge Granulation in a Bioreactor with a Low-Strength Wastewater Influent

Aerobic granulation in sequential sludge blanket reactor

[Cultivation of aerobic granules in a large pilot SBR with domestic sewage]