Pilot Study on Submerged Ultra -Filtration Substituting Sand Filtration for Drinking Water Treatment from Dongjiang River

SHEN Yu-dong,TIAN Jia-yu,LV Mou,CHEN Jie,LIN Jian-lu,LI Gui-bai

DOI: https://doi.org/10.3969/j.issn.1672-0946.2011.04.010

2011-01-01

Abstract:The feasibility and economy of hollow fiber(HF) membrane for ultrafiltration treatment of drinking water is highly dependent on the fouling behavior and corresponding cleaning operation.Pilot scale experiments with immersed HF membrane were conducted to investigate the effect of operating conditions of physical cleaning and chemical cleaning on the elimination of membrane fouling.The results showed: as compared with individual air bubbling or water backwashing,the combination of air and water cleaning could substantially improve the cleaning efficiency,as demonstrated by the increase of permeability restoration coefficient from 80% to 90%.To achieve the same cleaning effect(84.3% permeability restoration),39% of the water consumption could also be reduced by the combined air bubbling at 22.5 m3/(m2·h) and water backwashing at 140 L/(m2·h),when compared with individual water backwashing at 140 L/(m2·h).The optimized cleaning condition was determined as water backwashing at 40 L/(m2·h) combined with air bubbling at 45 m3/(m2·h) for 120~180 s.Under this condition,the permeability could be recovered to 93% of the initial value,with the water production rate higher than 94%.Furthermore,in the experiments,both HCl(pH≈2) and NaClO(150~250 mg/L) cleaning were shown to be able to remove the membrane foulants effectively;while NaOH was proved to be less efficient in the restoration of membrane permeability.An approximate logarithmic relationship was observed between the chemical cleaning efficiency and the soaking time of immersed HF membrane in the chemical solution.