Abstract:Microencapsulating sunflower oil, lemon and orange oil flavour was investigated using complex coacervation of whey protein/gum arabic (WP/GA). At pH 3.0-4.5, WP and GA formed electrostatic complexes that could be successfully used for microencapsulation purposes. The formation of a smooth biopolymer shell around the oil droplets was achieved at a specific pH (close to 4.0) and the payload of oil (i.e. amount of oil in the capsule) was higher than 80%. Small droplets were easier to encapsulate within a coacervate matrix than large ones, which were present in a typical shell/core structure. The stability of the emulsion made of oil droplets covered with coacervates was strongly pH-dependent. At pH 4.0, the creaming rate of the emulsion was much higher than at other pH values. This phenomenon was investigated by carrying out zeta potential measurements on the mixtures. It seemed that, at this specific pH, the zeta potential was close to zero, highlighting the presence of neutral coacervate at the oil/water interface. The influence of pH on the capsule formation was in accordance with previous results on coacervation of whey proteins and gum arabic, i.e. WP/GA coacervates were formed in the same pH window with and without oil and the pH where the encapsulation seemed to be optimum corresponded to the pH at which the coacervate was the most viscous. Finally, to illustrate the applicability of these new coacervates, the release of flavoured capsules incorporated within Gouda cheese showed that large capsules gave stronger release and the covalently cross-linked capsules showed the lowest release, probably because of a tough dense biopolymer wall which was difficult to break by chewing.

Study on the Microencapsulation of Walnut Oil

Preparation of walnut oil microcapsules employing soybean protein isolate and maltodextrin with enhanced oxidation stability of walnut oil

Microencapsulation of walnut oil using starch octenyisuccinate

Effects of fructooligosaccharide and soybean protein isolate in the microencapsulation of walnut oil

Olive Oil Microcapsule Prepared by the Complex Coacervation Method

Preparation and Oxidative Stability of Microcapsules Containing Pine Nut Oil by Complex Coacervation

Microencapsulation of oils using whey protein/gum Arabic coacervates

Effect of maltodextrin combination with gum arabic and whey protein isolate on the microencapsulation of gurum seed oil using a spray-drying method

Improved Physicochemical Properties and in Vitro Digestion of Walnut Oil Microcapsules with Soy Protein Isolate and Highly Oxidized Konjac Glucomannan As Wall Materials.

Study on the Optimum Processing Technology about Microcapsule of Silkworm Oil

Encapsulation and characterization of ω-3 medium- and long-chain triacylglycerols microencapsulated with different proteins as wall materials

Study on the preparation process of microcapsule instant walnut powder by walnut meal

[The Interaction of Oil Microcapsule Wall Materials Between Whey Protein and Acacia].

Preparation and Quality Evaluation of Flat Almond Oil Micro-Encapsulation

Influence of wall material combination on the lipid oxidation of the hazelnut oil microcapsules

Buttermilk as a wall material for microencapsulation of omega-3 oils by spray drying

Study on the preparation of garlic oil microcapsules with regenerated silk fibroin and gelatin as wall material

Optimisation of wall material composition of freeze–dried pumpkin seed oil microcapsules: Interaction effects of whey protein, maltodextrin, and gum Arabic by D–optimal mixture design approach

Inhibited the Walnut Oil Oxidation Through the Microcapsules That Consisted of (-)-epigallocatechin Gallate and Sodium Caseinate

Microencapsulation of Carvacrol by Complex Coacervation of Walnut Meal Protein Isolate and Gum Arabic: Preparation, Characterization and Bio-Functional Activity

Microencapsulation of DHA Algal Oil by Spray Drying