Abstract:A substantial amount of water is being used during Clean-in-Place (CIP) operation, and is transformed into wastewater that can cause eutrophication to the nearby ecosystem. The present study proposed the Nanofiltration (NF) - Forward Osmosis (FO) - Direct Contact Membrane Distillation (DCMD) to recover the cleaning agents and reclaim freshwater from the model CIP wastewater. NF steps were suggested as prefiltration steps to remove organic compounds from the CIP wastewater. NF steps reduced the lactose and protein contents by 100 % and 95.6 %, respectively. The permeates from NF steps were further managed by the integrated FO-DCMD system. Several draw salts such as NaCl, KCl, MgCl2, and CaCl2 were compared to investigate the influence on FO and DCMD performance. It was found that monovalent salts (NaCl and KCl) outperformed the divalent salts (MgCl2 and CaCl2) in terms of water flux for both FO and DCMD. This can be attributed to the lower viscosity and higher mass transfer coefficient. In addition, the replenishment costs of each salt were evaluated since salts loss occurred during FO and DCMD operation. The cost evaluation revealed that NaCl is most the cheapest salts per reclaimed water. All of this observation indicates that NaCl is preferred in terms of water flux and replenishment cost. The NF permeate kept concentrated using the integrated FO-DCMD or single FO with 2 M of NaCl. Compared to a single FO that showed a consistent decline in draw solution concentration, FO-DCMD could maintain the concentration of the draw solution. Despite the constant concentration, flux decline of FO was observed due to fouling formation caused by the high-temperature operation. However, the FO-DCMD could accomplish the recovery of pure water. Finally, the cleaning agents recovered by the NF-FO-DCMD showed the cleaning efficacy comparable to the fresh NaOH. These results suggest the potential of the proposed system to manage the CIP wastewater.

Recovery of clindamycin from fermentation wastewater with nanofiltration membranes.

Hybrid Nanofiltration–membrane Crystallization System for the Treatment of Sulfate Wastes

Desalting and Recovering Naphthalenesulfonic Acid from Wastewater with Concentrated Bivalent Salt by Nanofiltration Process

Selective Separation of Chloride and Sulfate by Nanofiltration for High Saline Wastewater Recycling

Enhancing nanofiltration performance for antibiotics/NaCl separation via water activation before microwave heating

Antibiotics separation from saline wastewater by nanofiltration membrane based on tannic acid-ferric ions coordination complexes

Sequential high-recovery nanofiltration and electrochemical degradation for the treatment of pharmaceutical wastewater

Fouling of the Nanofiltration Membrane NF270 Used for Separation of Fermentation Broths: Impact of Feed Pretreatment Process

Nanofiltration in Pilot Scale for Wastewater Reclamation: Long-term Performance and Membrane Biofouling Characteristics

Effects of returning NF concentrate on the MBR-NF process treating antibiotic production wastewater

Clean-In-Place (CIP) wastewater management using nanofiltration (NF)-forward osmosis (FO)-direct contact membrane distillation (DCMD): Effects of draw salt

The effects of operating parameters on spiramycin removal by nanofiltration membrane.

A novel loose nanofiltration membrane with superior anti-biofouling performance prepared from zwitterion-grafted chitosan

The Application of the Nanofiltration Membrane NF270 for Separation of Fermentation Broths

Pilot-scale fabrication of nanofiltration membranes and spiral-wound modules

Study on Reuse of Nanofiltration Membranes for Application in the Treatment of Synthetical Electroplating Wastewater

In Situ Formation of Silver Nanoparticles Induced by Cl-Doped Carbon Quantum Dots for Enhanced Separation and Antibacterial Performance of Nanofiltration Membrane

Desalination and recovery of iminodiacetic acid (IDA) from its sodium chloride mixtures by nanofiltration

Two birds with one stone: by-product HCl consumption and in-situ template formation for high-performance nanofiltration membranes fabrication

Sustainable and ultrafast antibiotics removal, self-cleaning and disinfection with electroactive metal-organic frameworks/carbon nanotubes membrane

Treatment of Low Level Radioactive Wastewater by Means of Nf Process