Abstract:The recently developed tough and self-healing hydrogels, containing a large number of physical bonds, have found widespread applications in bioengineering and soft electronics. Owing to the sophisticated physical interactions and organization, these hydrogels often demonstrate structural heterogeneities, which strongly influence their mechanical performances. Using poly(N,N-dimethyl acrylamide-co-methacrylic acid) hydrogels (P(DMAA-co-MAAc)) with dynamic hydrogen bonds (H-bonds) as a model system, the structural characterization has been carried out in this study using small-angle X-ray scattering (SAXS) and small-angle neutron scattering (SANS) analyses, along with exploring the influence of the structure on the mechanical properties. By systematically tuning the polymer composition, including the monomer fraction and chemical cross-linking density, two different hydrogel regions with distinct mechanical properties were observed: the swollen regions and shrunk regions. The former was mechanically weak, whereas the latter exhibited a tough behavior. Both types of hydrogels were noted to be highly heterogeneous, which results from the nanoscale spatial polymer concentration fluctuations at ∼100 nm scale. Combined with the contrast variation utilizing SANS, the structure parameters, including the polymer volume fraction of the dense and sparse regions, volume fraction occupied in the space, and average correlation length of the long-range and short-range heterogeneous structures, were explored using a scaling model based on a two-phase system composed of the densely and sparsely cross-linked regions. Using in situ SAXS, the microscopic deformation of the tough and shrunk hydrogels was noted to follow the affine deformation, while a significantly non-affine deformation was observed in the swollen hydrogels, which might have led to the different mechanical performances of these materials.The Supporting Information is available free of charge at https://pubs.acs.org/doi/10.1021/acs.macromol.1c01064.Swelling volume ratio of hydrogels 0.14-0.2% during the drying–swelling cycle (Figure S1); FT-IR spectra of PDMAA, PMAAc, and P(DMAA-co-MAAc) and temperature dependence of FT-IR spectrum of P(DMAA-co-MAAc) (Figure S2); semi-empirical quantum chemical calculations for revealing the conformation features and their interaction in water (Figure S3); tensile stress–strain curves of P(DMAA-co-MAAc) hydrogels f-0.1% with various f values (0.12, 0.13, and 0.15) and P(DMAA-co-MAAc) hydrogels 0.14-x with various x values (0.05, 0.1, and 0.15%) (Figure S4); 1D scattering intensity as a function of the scattering vector q under various stretch ratios for the hydrogels f-0.1% with the molar fraction of DMAA varying from 0.12 to 0.15 and hydrogels 0.14-x with the chemical cross-linking density ranging from 0.05 to 0.15% (Figures S5 and S6); stretch-induced structure evolution of the swollen hydrogel 0.14-0 (Figure S7); tensile stress–strain curve of hydrogel 0.14-1% and the corresponding Mooney–Rivlin plot (Figure S8); and structural parameters of the swollen and shrunk hydrogels (Table S1) (PDF)This article has not yet been cited by other publications.

Dynamic Cell Behavior on Synthetic Hydrogels with Different Charge Densities

Tuning of Cell Proliferation on Tough Gels by Critical Charge Effect

Cell Proliferation and Cell Sheet Detachment from the Positively and Negatively Charged Nanocomposite Hydrogels.

Synthetic Hydrogels As Scaffolds for Manipulating Endothelium Cell Behaviors

Effect of particle size and charge on the network properties of microsphere-based hydrogels

Understanding and Regulating Cell-Matrix Interactions Using Hydrogels of Designable Mechanical Properties

Dual Network Formation in Polyelectrolyte Hydrogel Via Viscoelastic Phase Separation: Role of Ionic Strength and Polymerization Kinetics

Dynamic Hydrogels with Viscoelasticity and Tunable Stiffness for the Regulation of Cell Behavior and Fate

Responsiveness of Charged Double Network Hydrogels to Ionic Environment

Adhesion, Spreading, and Proliferation of Endothelial Cells on Charged Hydrogels

Zwitterion-Modified Nanogel Responding to Temperature and Ionic Strength: A Dissipative Particle Dynamics Simulation

Hydrogels with Independently Controlled Adhesion Ligand Mobility and Viscoelasticity Increase Cell Adhesion and Spreading

High Tensibility and Ph-Responsive Swelling of Nanocomposite Hydrogels Containing the Positively Chargeable 2-(Dimethylamino)ethyl Methacrylate Monomer

Selective Cell Spreading, Proliferation, and Orientation on Micropatterned Gel Surfaces.

Regulation of Cell Adhesion on Physically Crosslinked Hydrogels Composed of Amino Acid‐Based Polymers by Changing Elastic Modulus Using Shape Fix/Memory Properties

Dynamic Behavior and Spontaneous Differentiation of Mouse Embryoid Bodies on Hydrogel Substrates of Different Surface Charge and Chemical Structures.

Dynamic cell-adaptable hydrogels with a moderate level of elasticity promote 3D development of encapsulated cells

Tough Hydrogels with Dynamic H-Bonds: Structural Heterogeneities and Mechanical Performances

Synthesis and Properties of pH-Responsive Cationic Microgels

Osmotic Swelling Behavior of Surface-Charged Ionic Microgels

Flocculation and Aggregation Behavior of Doubly Responsive Microgel