Abstract:The dc-dc topologies with capacitive output filter are going to be widely used especially for high-output current applications because of its inherent advantages in the lower voltage stress on rectifiers and the smaller occupied printed circuit board layout area at the secondary side. However, the parasitic resonance between the equivalent leakage inductance of the power transformer and the equivalent output junction capacitance of the rectifier still practically exists in the center-tapped rectification configuration, which leads to considerable voltage ringing on the rectifier and then results in the utilization of the rectifier with much higher breakdown voltage rate and the decrease of conversion efficiency. Moreover, the relatively larger output-current ripple induces the both larger conduction loss in the secondary-side windings of the power transformer and the capacitive output filter. In this paper, a novel symmetrical rectifier configuration is proposed, which can effectively clamp the practical voltage stress on the rectifier without any parasitical voltage spike and reduce the output-current ripple due to the bypass effect of the auxiliary flying-balancing capacitors. The leakage inductance and the output filter capacitor can be treated as an inherent small LC filter to reduce the output voltage ripple further. Based on the theoretical analysis and the optimal design considerations, a 300-W lab-made LLC resonant dc-dc converter with this proposed configuration is built up to verify its advantages in high conversion efficiency.

High Efficiency Capacitive Rectifier Configuration

A Synchronous Rectified Flyback AC-DC Converter Using Capacitor-Coupled Isolated Communication

A Novel Symmetrical Rectifier Configuration with Low Voltage Stress and Ultralow Output-Current Ripple

Full-Bridge LLC Resonant Converter with Parallel-Series Transformer Connection and Voltage Doubler Rectifier

Evaluation of Output Filter Capacitor Current Ripples in Single Phase PFC Converters

Flying-Capacitor Based Hybrid LLC Converters with Input Voltage Auto-Balance Ability for High Voltage Applications

A New Design Method for High Efficiency DC-DC Converters with Flying Capacitor Technology

High-Efficiency High-Density RDCX Modules Cascaded with CHB PFC Stage

Capacitor Voltage Ripple Reduction of A 4-Level Hybrid Clamped Converter Using Switching State Redundancy for Medium-Voltage Drive

A Symmetrical Control Scheme for a Resonant Switched-Capacitor Converter with Inverted Output Voltage

A Second Harmonic Voltage Suppression Strategy Based on the Novel Split-Capacitor Three Phase LCL Dual Active Bridge Converter in Single-Phase AC/DC System

Design Consideration of the Voltage Stress Clamping Rectifier Configuration Used for the Front-End Dc/Dc Converter with the Capacitive Output Filter

Capacitor Design Optimization And Power Balance Control For Llc Resonant Converter Based Power Electronic Traction Transformer

The Analysis and Evaluation for the Leakage Inductance Effects of Two Front-End Dc/Dc Converters with Capacitive Output Filter

An Isolated High Step-Up Converter Based on the Active Secondary-Side Quasi-Resonant Loops

A High Power Density Multi-Pulse Rectifier Based on Harmonic Reduction Technology at DC Link

A novel bridgeless flying capacitor multilevel rectifier

High step-up isolated DC-DC converter with multi-cell diode-capacitor network

An Improved LLC Resonant Converter with Phase-Shift Controlled Dynamic Series-Parallel Reconfiguration-Windings for Hold-Up Applications

A Novel Unidirectional Three-Phase Multilevel Rectifier Composed of Star-Connected Three Single-Phase Topology Based on Five-Level Flying Capacitor DC–DC Converter

A Step-up Series-parallel Resonant Switched-capacitor Converter with Extended Line Regulation Range