Production of 5-Hydroxymethylfurfural in Ionic Liquids under High Fructose Concentration Conditions

Changzhi Li,Zongbao K. Zhao,Aiqin Wang,Mingyuan Zheng,Tao Zhang

DOI: https://doi.org/10.1016/j.carres.2010.07.003

IF: 2.975

2010-01-01

Carbohydrate Research

Abstract:Acid-promoted, selective production of 5-hydroxymethylfurfural (HMF) under high fructose concentration conditions was achieved in ionic liquids (ILs) at 80°C. A HMF yield up to 97% was obtained in 8min using 1-butyl-3-methylimidazolium chloride ([C4mim]Cl) catalyzed with 9mol% hydrochloric acid. More significantly, an HMF yield of 51% was observed when fructose was loaded at a high concentration of 67wt% in [C4mim]Cl. Water content below 15.4% in the system had little effect on HMF yield, whereas a higher water content was detrimental to both reaction rate and HMF yield. In situ NMR analysis suggested that the transformation of fructose to HMF was a highly selective reaction that proceeded through the cyclic fructofuranosyl intermediate pathway. This work increased our capacity to produce HMF, and should be valuable to facilitate cost-efficient conversion of biomass into biofuels and bio-based products.