Abstract:Zn modified ZSM-5 zeolite supported Ni bifunctional catalysts were prepared by in-situ hydrothermal synthesis (Zn-Ni-ZSM-5), co-impregnation method (Zn-Ni/ZSM-5) as well as combining in-situ hydrothermal synthesis of Zn-ZSM-5 and sequential impregnation of Ni (Ni/Zn-ZSM-5) and used for the selective converting olefin to aromatics applicable for FCC gasoline hydro-upgrading. The Lewis (L) acid sites generated by ZnOH+ species and hydrogenation active sites from Ni0 species were varied with preparation method, in which their locations at the external surface or micropores of zeolite changed the acid properties of catalysts. Comparing to the Zn-Ni/ZSM-5 from the co-impregnation method, direct in-situ hydrothermal method could incorporate Zn and Ni species within zeolite, which makes the strong interaction between the metal species and the framework Al to form medium-strong L acids (ZnOH+/NiOH+). This leads to the decrease of ratio of Brønsted acid sites to L acid sites (B/L) from 0.40 to 0.12 and the difficulty in reducing of Ni cations to Ni0 from 57% to 30% Ni0 percent. Ni/Zn-ZSM-5 sample prepared by incorporating Zn species into micropores and sequential depositing Ni species at the external surface of zeolite possesses a low B/L ratio similar to Zn-Ni-ZSM-5 (0.20 versus 0.12) but a much higher Ni0 percent (52% versus 30%). Zn-Ni-ZSM-5 shows closer intimacy between Zn and Ni species comparing to Zn-Ni/ZSM-5 and Ni/Zn-ZSM-5. For the 1-hexene aromatization, the formed iso-alkene at acid sites was quickly saturated to iso-alkanes by the adjacent Ni0 particles over Ni-Zn-ZSM-5 catalyst in hydrogen steam. However, the location of aromatization active sites (ZnOH+, L acid sites) in micropores and hydrogenation active sites (Ni0 species) on external surface of Ni/Zn-ZSM-5 makes the tandem conversion of n-alkene → iso-alkene → aromatics, rather than the n-alkene → iso-alkene → iso-alkane. Thus, Zn-Ni-ZSM-5 with close intimacy of ZnOH+ and Ni0 particles shows a high iso-alkane selectivity (27.9% iC4 +), while Ni/Zn-ZSM-5 exhibits a high aromatics selectivity (39.6 %) in the conversion of 1-hexene in hydrogen steam. Similar results have also found in the conversion of n-heptane. Here, the control of the intimacy of Zn and Ni in ZSM-5 zeolites has been realized to be a good protocol to adjust the selective conversion of olefins/alkanes to aromatics versus iso-alkanes.

The Aromatization of Fcc Gasoline Fraction on Modified Hzsm-5

Enhancement in the Aromatic Yield from the Catalytic Fast Pyrolysis of Rice Straw over Hexadecyl Trimethyl Ammonium Bromide Modified Hierarchical HZSM-5

XPS CHARACTERIZATION AND PROPANE AROMATIZATION OVER ZINC PROMOTED HZSM-5 CATALYSTS

Liquefied Petroleum Gas Aromatization to High Octane Gasoline over Zsm-5 Zeolite Catalyst at Low Temperature

Synthesis and consequence of Zn modified ZSM-5 zeolite supported Ni catalyst for catalytic aromatization of olefin/paraffin

Aromatization of Yanhua Fcc Gasoline

Stability of Zn/HZSM-5 Catalysts in Reaction Regeneration Process of Propane Aromatization

Effect of Methanol on Catalytic Performance of Hy Zeolite for Desulfurization of Fcc Gasoline by Alkylation

Aromatization Reactions of Three Gasoline Fractions

Catalytic Cracking of Fatty Acid Methyl Esters for the Production of Green Aromatics Using Zn-Modified HZSM-5 Catalysts

Aromatization of Methanol over La/Zn/HZSM-5 Catalysts

PRODUCT DISTRIBUTION AND REACTION KINETICS IN THE AROMATIZATION OF YANHUA FCC GASOLINE

Influence of Aromatization Reaction Conditions in the Presence of Hzsm-5 Catalyst

Relay and Feedback Conversion Effect of Hydrocarbons between ZSM-5 Grains on Product Selectivity and Coke Formation during Methanol Aromatization

Zinc Speciation and Propane Dehydrogenation in Zn/H-ZSM-5 Catalysts

Collaborative Effect of Zinc and Phosphorus on the Modified HZSM-5 Zeolites in the Conversion of Methanol to Aromatics

Enhanced light aromatics yield from lignite pyrolysis by remedying the acid sites of different hierarchical HZSM-5

Methane Aromatization Under O 2 -Free Conditions on Zinc Modified Mo/HZSM-5 Catalyst

Improving the Hydrothermal Stability of ZSM-5 Zeolites in 1-Octene Aromatization by Sequential Alkali Treatment and Phosphorus Modification

Study on Aromatization of Ethylene on Zn/ZSM-5 Zeolite Catalyst

Characterization of Zn Promoter in Zno/Hzsm-5 Catalyst for Propane Aromatization