Abstract:Mechanism experiments were performed to investigate NOr r formation and reduction during the combustion of high-ash, low-volatile coal. Additionally, industrial-scale trials were conducted to study the effects of air-staging degree on the combustion and NOr r emission characteristics of high-ash coal on a 350 MW supercritical down- fired boiler. The results showed that the total BET specific surface area, total pore volume and porosity values of high-ash coal (HAC) and ultra-high-ash coal (UHAC) were all larger than those of normal-ash coal (NAC), whereas NAC contained more N-5 and N-6 than HAC and UHAC. The carbon layer structure of HAC char was less ordered and the content of hydroxyl group was relatively high. The overall NO reduction ratio obtained using the HAC char was higher than the value for the UHAC char. However, in the high temperature range of 1300-1400 degrees C, NO reduction associated with UHAC char was accelerated because of catalysis by ash. On increasing the excess oxygen ratio lambda from 1.0 to 1.2, the char-N conversion shown by the UHAC char slowly increased and remained the lowest among the three chars. When burning UHAC, as the ratio of secondary to tertiary air fluxes, R st , was decreased from 1.56 to 0.57, heating of the fuel-rich coal/air flow slowed and pulverized coal combustion was inhibited. The situation associated with HAC was different. At the R st of 1.11, the ignition distance of fuel-rich flow was the shortest at 1.50 m, and the overall temperature in the furnace was the highest. However the NOr r emissions at the furnace exit were as high as 715 mg/m3 3 (6 % O2) 2 ) in this condition. Decreasing R st to 0.57 reduced this value to 634 mg/m3 3 (6 % O2) 2 ) with carbon levels in the fly ash and slag of 5.17 % and 3.67 %, respectively. Air-staging combustion is evidently a reasonable approach to controlling NOr r emissions when burning HAC. While for UHAC, it was necessary to appropriately reduce the air-staging degree to enhance combustion and maintain low NOr r emissions.

Increasing the CO2 Purity in the Low Pressure Flash Gas from the NHD Decarbonization Process

Optimization of cryogenic CO2 purification for oxy-coal combustion

Operation enhancement of the H 2 shaft furnace: a numerical study on the impact of N 2 mixing in feed gas

Sustainable Preparation of High-Calorific Value and Low-N and S Energy Products Through the Low-Temperature Alkali Fusion of Coal Gasification Fine Ash

Low-pressure Acetylene Plant Supplied with New Purification Technique

Achieving an ultralow emission of nitrogen oxides by using activated carbon with hydrophobic modification

Computational Fluid Dynamics Simulation on Oxy-Fuel Combustion Performance of a Multiple-Burner Furnace Firing Coking Dry Gas

Analysis on Purification Degree in Treatment of Phenol-cyanogen Wastewater and Flue Gas in the Coking Process

Optimization of the Process of Antisolvent Crystallization of Carbonized Ammonia with a Low Carbon-to-nitrogen Ratio

Current Advances of Integrated Processes Combining Chemical Absorption and Biological Reduction for NO X Removal from Flue Gas

Elevated Temperature Pressure Swing Adsorption Process for Reactive Separation of CO/CO2 in H2-rich Gas

Experimental Study of Flue Gas Condensing Heat Recovery Synergized with Low NOx Emission System

Experimental Study of Nitrogen Conversion During Char Combustion under a Pressurized O2/H2O Atmosphere

Industrial test of post combustion CO2 capture by reactive absorption with two new solvents in natural gas power plant

Facilitating CO2–CH4 Reforming Into Syngas and Useful Chemicals by Water‐Cooled Dielectric Barrier Discharge Plasma: Effect of Discharge Power, Gas Mixing, and Mechanism Insight

Preliminary Study On Co2 Processing In Co2 Capture From Oxy-Fuel Combustion

Revealing roles of CO2 and N2 in pressurized hydrothermal carbonization process for enhancing energy recovery and carbon sequestration

Transformation mechanism of C and N during rapid devolatilization of pulverized coal particles under the pressurized atmospheres

Experimental Study on Flame Temperature Distribution and Pollutant Emission Characteristics of CH 4 Mixed with CO 2 /N 2 /H 2 Combustion

Using Process Simulation Technology to Control Dry Gas Quality for Delayed Coking Units

Studies on NOx Formation and Reduction Characteristics in High-Ash, Low-Volatile Coal Combustion by Mechanism Experiments and Industrial-Scale Trials