Abstract:Cu/ZnO catalysts with varied Cu/(Cu + Zn) molar ratios were prepared by a facile solid-state method. The Cu/(Cu + Zn) molar ratio displayed a significant effect on the oxygen vacancy formation of the calcined catalysts, thereby influencing the CuO–ZnO interaction and the reducibility of CuO. The Cu/(Cu + Zn) molar ratio also exhibited a significant effect on Cu0 surface area, oxygen vacancy, the ratio of ZnO(002) plane to ZnO(100) plane, as well as the basicity and acidity of the reduced catalysts, thereby affecting the catalytic performance for low-temperature methanol synthesis from syngas containing CO2. The correlations of methanol space time yield (STY) versus the physicochemical characteristics of Cu/ZnO catalysts were studied. The catalyst with equal amounts of Cu and Zn displayed the best catalytic activity owing to higher Cu0 surface area, more oxygen vacancy and ZnO(002) plane, as well as more moderately basic sites.The Supporting Information is available free of charge at <a class="ext-link" href="/doi/10.1021/acsami.0c18600?goto=supporting-info">https://pubs.acs.org/doi/10.1021/acsami.0c18600</a>.Reaction equipment; Cu 2p and Zn 2p XPS spectra of the calcined catalysts; correlation between the maximum reduction temperature and Ovacancy/Olattice ratio; Cu 2p and Zn 2p XPS spectra of the reduced catalysts; Cu LMM Auger spectrum of CZ-R-0.5 catalyst; reaction route of high-temperature ICI process for methanol synthesis; new reaction route of methanol synthesis at low temperatures using methanol itself as a catalytic promoter; variation of total carbon conversion of CZ-R-0.5 catalyst with time on stream; XRD patterns of the CZ-R-0.5 sample before and after reaction; and results of comparison with CO2 and without CO2 (<a class="ext-link" href="/doi/suppl/10.1021/acsami.0c18600/suppl_file/am0c18600_si_001.pdf">PDF</a>)This article has not yet been cited by other publications.

Influence of Cu/Zn atomic ratio on properties of CuO-ZnO/Al2O3 catalysts in methanol synthesis

Surface Properties of CuO/ZnO/Al_2O_3 Catalyst for Methanol Synthesis in Slurry Reactor

Preparation of CuO/ZnO/Al2O3 Catalysts for Methanol Synthesis Using Parallel-Slurry-mixing Method

Modulation of Al2O3 and ZrO2 composite in Cu/ZnO-based catalysts with enhanced performance for CO2 hydrogenation to methanol

Structure–Performance Correlations over Cu/ZnO Interface for Low-Temperature Methanol Synthesis from Syngas Containing CO 2

Influence of Cu/Al Ratio on the Performance of Carbon-Supported Cu/ZnO/Al2O3 Catalysts for CO2 Hydrogenation to Methanol

A High Activity Cu/ZnO/Al2O3 Catalyst for Methanol Synthesis: Preparation and Catalytic Properties

Structure-Performance Correlations over Cu/ZnO Interface for Low-Temperature Methanol Synthesis from Syngas Containing CO2.

PROMOTING EFFECT OF ZrO2 TO CATALYTIC PERFORMANCE OF COPPER-BASED CATALYST FOR METHANOL SYNTHESIS

Preparing methods of CuO/ZnO/Al2O3 catalysts for the synthesis of methanol

High-Performance Cu/ZnO/Al 2 O 3 Catalysts for CO 2 Hydrogenation to Methanol

Promoting effect of an aluminum emulsion on catalytic performance of Cu-based catalysts for methanol synthesis from syngas

Synthesis of a Cu@ZnO1-x/Al2O3 Catalyst with High-Density ZnO1-x-Cu Interfacial Sites for Enhanced CO2 Hydrogenation to Methanol

XPS Studies of Cu/ZnO/Al2O3 Ultra-Fine Catalysts Derived by a Novel Gel Oxalate Co-Precipitation for Methanol Synthesis by CO2+H2

Effective Cu/ZnO/Al2O3 Catalyst for Methanol Production: Synthesis, Activation, Catalytic Performance, and Regeneration

Performance of Cu-Mn-Zn/ZrO2 catalysts for methanol synthesis from CO2 hydrogenation: The effect of Zn content

Effect of the Zr/Al Molar Ratio on the Performance of Cu/ZrO2–Al2O3 Catalysts for Methanol Steam Reforming

Effect of Zr on CuO/ZnO/Al_2O_3 Precursor Composition,Structure and Catalysis for Methanol Synthesis

Effect of preparation methods of aluminum emulsions on catalytic performance of copper-based catalysts for methanol synthesis from syngas

A Modified Two-Step Coprecipitation Method Provides Better CuZnO/Al2O3 Methanol Synthesis Catalyst with More Uniform Distribution of Alumina

Influence of the Calcination on the Activity and Stability of the Cu/ZnO/Al2O3 Catalyst in Liquid Phase Methanol Synthesis