Abstract:The membrane separation process such as MBR (membrane bioreactor) in wastewater treatment would be more competitive and environmental friendly, if membrane fouling was reduced and higher permeate flux was maintained without consuming extra material or extra energy. For this, a new helical membrane module with an inside helical spacer and outside cover membrane was designed which reduced filtration resistance. It increased mass transfer coefficients by 1.46–1.69 times that of flat membrane modules, when aeration level was at 0.2m3/h and the liquid cross flow rate was low (∼12cm/h). Similarly increased were the ratios of pseudo-steady flux to initial flux (Fs/Fo) for the helical membranes when the final helical angle was between 45° and 180° during the 1 or 2h dynamic filtration of 500mg/L kaolin suspension under constant trans-membrane pressure (2.8 or 3.2kPa). The increased mass transfer is affected by liquid cross flow. When the cross flow rate was more than doubled (29cm/h), the 90° helical membrane could maintain a relatively higher flux than the flat membrane at lower aeration intensity (0.1m3/h). The increase of aeration levels from 0.1 to 0.14 and to 0.2m3/h reduced cake layer deposition and fouling in the 135° helical membranes than in the flat membranes. More obvious decrease of filtration resistance in helical membranes than the flat membrane is attributed to the effectively enhanced turbulent mass transfer by the helical membrane surface distribution in the flow field, and the intensified interfacial turbulence/reduced boundary layer thickness by aeration bubbles and liquid flow. The maximal 48–69% flux increase obtained without extra energy consumption is a real advantage of the helical membranes.

Filtration of Anaerobic Sludge Mixed Liquor Using Double-Shaft Rotary Ultrafiltration Membrane Module

[Membrane Fouling Control in a Free-End Comb-Like Hollow Fiber Membrane Bioreactor].

Study on the Membrane Fouling of the Process of Using Two Layer Flat-Sheet Membrane for Sludge Thickening and Water Reuse

Membrane fouling mechanisms in the process of using flat-sheet membrane for simultaneous thickening and digestion of activated sludge

Experimental study on selection of microfiltration membranes in aerobic membrane bioreactor

Sludge rheological and physiological characteristics in a pilot-scale submerged membrane bioreactor

Pilot-scale Study on Flat Sheet Membrane for Sludge Thickening

Membrane Fouling Properties under Different Filtration Modes in a Submerged Membrane Bioreactor

The process of using flat-sheet membrane for thickening and digestion of waste activated sludge.

Development of Submerged Anaerobic Double-shaft Rotating Membrane Bioreactor

Relationship Between Sludge Characteristics and Membrane Flux Determination in Submerged Membrane Bioreactors

Identification of sustainable flux in the process of using flat-sheet membrane for simultaneous thickening and digestion of waste activated sludge.

Research of Membrane Fouling Performance in A Submerged Double-Shaft Rotary Anaerobic Membrane Bioreactor

Pilot scale application of a rotating hollow fibre membrane for direct membrane filtration of domestic wastewater

The configuration and application of helical membrane modules in MBR

Effect of Sludge Properties on the Filtration Characteristics of Self-Forming Dynamic Membranes (sfdms) in Aerobic Bioreactors: Formation Time, Filtration Resistance, and Fouling Propensity

Municipal Sewage Treated by a Pilot-Scale Membrane Biological Reactor

Microfiltration performance with two-phase flow

Operating process parameters and performance of aerobic granular sludge dynamic membrane bioreactor

Study on ultrafiltration for surface water by a polyvinylchloride hollow fiber membrane

A New Helical Membrane Module for Increasing Permeate Flux