Abstract:Summary Consolidated bioprocessing (CBP) is a convenient and cost‐efficient strategy to produce single cell oils ( SCOs ) from cellulose‐based substrates . In this study , Penicillium P‐2 having both effective cellulose degradation and lipid accumulation was isolated from 20 cellulolytic fungi . The SCOs of the strain P‐2 were mainly composed of palmitic acid ( C16 :0 , 21 .05% ) , oleic acid ( C18 :1 , 22 .43% ) and linoleic acid ( C18 :2 , 27 .78% ) . Fermentation experiments of the strain P‐2 showed that maximum lipid yields of 0 .65 g/L and 40 .13 mg/g ( per gram dry mass of initial solid substrate) could be obtained by submerged fermentation ( SmF) from cellulose and solid‐state fermentation (SSF) from wheat straw and bran mixture , respectively . The results from the two CBP indicated that the strain P‐2 had a potential to be a promising low‐cost oil producer using cellulose‐based substrates . The further analysis for lipid accumulation and cellulase secretion of the strain P‐2 suggested that the cellulase secretion of the strain P‐2 might play a key role in the lipid production . The submerged fermentation with exogenous cellulase addition by the strain P‐2 demonstrated that the higher exogenous cellulase dosages could lead to higher lipid production and the lipid yield would increase up to 0 .83 g/L with the addition of 24 IU /g cellulase . A highly significant positive correlation between the filter paper activity ( FPA) and the lipid yield in the strain P‐2 was further observed on the data pooled from the SSF parameter treatments ( P < 0 .01) . When the detected FPA in SSF system increased from 1 .0 IU /g to 3 .5 IU /g , the lipid yield was also increased from 26 .24 mg/g to 40 .13 mg/g with the increment of 52 .93% . All these analyses suggest that the weak cellulase secretion of the strain P‐2 is an important cause of the low lipid yield , so the regulation of endogenous cellulase secretion might be a feasible strategy for enhancing lipid production of the strain P‐2 .

Screening of Yeasts for Single Cell Protein Production by Soybean Whey Fermentation

Yeasts for single-cell protein production by soybean whey fermentation

Selection of Yeasts and the Culture Conditions for Single Cell Protein Production from Soy Protein Wastewater by Fermentation

Screening of substrates and strains for producing single cell protein by fungal fermentation in distillery waste

Microbial community-based production of single cell protein from soybean-processing wastewater of variable chemical composition

Microbial Protein Enrichment and Treatment of Winery Residue from Fungi and Yeast by Syntrophic Fermentation

High-yield Production of Single-Cell Protein from Starch Processing Wastewater Using Co-Cultivation of Yeasts.

Screening of Yeast with High-Yield Single Cell Protein and Preliminary Optimization of Its Culture Codition

Food-grade Single-Cell Protein Production, Characterization and Ultrafiltration Recovery of Residual Fermented Whey Proteins from Whey

Mixed culture of Kluyveromyces marxianus and Candida krusei for single-cell protein production and organic load removal from whey.

Exploring the feasibility of biotransforming salted soy whey into a soy sauce-like condiment using wine yeast Torulaspora delbrueckii and soy sauce yeasts Zygosaccharomyces rouxii and Candida versatilis as single starter cultures

Studies on Single Cell Protein(scp) Production by Solid-State Culture Using Vancomycin Fermentation Residue

From coffee waste to nutritional gold: bioreactor cultivation of single‐cell protein from Candida sorboxylosa

Two-stage fermentation enhanced single-cell protein production by Yarrowia lipolytica from food waste.

Consolidated Bioprocessing Performance of Penicillium Sp P-2 in Cellulose-Based Substrates for Low-Cost Oil Production

Simultaneous Single-Cell Protein Production and COD Removal with Characterization of Residual Protein and Intermediate Metabolites During Whey Fermentation by K. Marxianus.

Solid-state Fermentation with Rhizopus Oligosporus RT-3 Enhanced the Nutritional Properties of Soybeans

Recovery and upcycling of residual lactic acid and ammonium from biowaste into yeast single cell protein

Dynamic changes of microbial communities during natural solid-state fermentation of soybean meal and isolation of dominant bacteria for peptide production

Growth and metabolism of halophilic Candida versatilis and Tetragenococcus halophilus in simultaneous and sequential fermentation of salted soy whey

SOYBEAN LECITHIN ENHANCED CELLULASE PRODUCTION BY PENICILLIUM OXALICUM JG IN A SCALED-UP BIOCONVERSION PROCESS