Abstract:Bioreactor scale-up from the laboratory scale to the industrial scale has always been a pivotal step in bioprocess development. However, the transition of a bioeconomy from innovation to commercialization is often hampered by performance loss in titer, rate and yield. These are often ascribed to temporal variations of substrate and dissolved oxygen (for instance) in the environment, experienced by microorganisms at the industrial scale. Oscillations in dissolved oxygen (DO) concentration are not uncommon. Furthermore, these fluctuations can be exacerbated with poor mixing and mass transfer limitations, especially in fermentations with filamentous fungus as the microbial cell factory. In this work, the response of glucose-limited chemostat cultures of an industrial Penicillium chrysogenum strain to different dissolved oxygen levels was assessed under both DO shift-down (60% → 20%, 10% and 5%) and DO ramp-down (60% → 0% in 24 h) conditions. Collectively, the results revealed that the penicillin productivity decreased as the DO level dropped down below 20%, while the byproducts, e.g., 6-oxopiperidine-2-carboxylic acid (OPC) and 6-aminopenicillanic acid (6APA), accumulated. Following DO ramp-down, penicillin productivity under DO shift-up experiments returned to its maximum value in 60 h when the DO was reset to 60%. The result showed that a higher cytosolic redox status, indicated by NADH/NAD+, was observed in the presence of insufficient oxygen supply. Consistent with this, flux balance analysis indicated that the flux through the glyoxylate shunt was increased by a factor of 50 at a DO value of 5% compared to the reference control, favoring the maintenance of redox status. Interestingly, it was observed that, in comparison with the reference control, the penicillin productivity was reduced by 25% at a DO value of 5% under steady state conditions. Only a 14% reduction in penicillin productivity was observed as the DO level was ramped down to 0. Furthermore, intracellular levels of amino acids were less sensitive to DO levels at DO shift-down relative to DO ramp-down conditions; this difference could be caused by different timescales between turnover rates of amino acid pools (tens of seconds to minutes) and DO switches (hours to days at steady state and minutes to hours at ramp-down). In summary, this study showed that changes in oxygen availability can lead to rapid metabolite, flux and productivity responses, and dynamic DO perturbations could provide insight into understanding of metabolic responses in large-scale bioreactors.

Effects of Different Oxygen-supply Modes on Biomass of Acetobacter xylinum

Effects of Oxygen Tension on the Microbial Community and Functional Gene Expression of Aerobic Methane Oxidation Coupled to Denitrification Systems

Effect of organic loading on semi-continuous anaerobic fermentation parameters of Chinese medicinal herb residues

Mixomics analysis of Bacillus subtilis: effect of oxygen availability on riboflavin production

H2 drives metabolic rearrangements in gas-fermenting Clostridium autoethanogenum

Impact of hydromechanical stress on CHO cells' metabolism and productivity: Insights from shake flask cultivations with online monitoring of the respiration activity

Two-stage oxygen supply strategy based on energy metabolism analysis for improving acetic acid production by Acetobacter pasteurianus

New insights into syntrophic ethanol oxidation: Effects of operational modes and solids retention times

Insights into the spatial effects of carbon source type on oxygen mass transfer mechanism and microbial community characteristics

Effect of dissolved oxygen on heterotrophic denitrification using poly(butylene succinate) as the carbon source and biofilm carrier.

Enhanced biological nitrogen removal under low dissolved oxygen in an anaerobic-anoxic-oxic system: Kinetics, stoichiometry and microbial community

Power to biogas upgrading: Effects of different H 2 /CO 2 ratios on products and microbial communities in anaerobic fermentation system

Changes in Oxygen Availability during Glucose-Limited Chemostat Cultivations of Penicillium chrysogenum Lead to Rapid Metabolite, Flux and Productivity Responses

An industrial perspective on metabolic responses of Penicillium chrysogenum to periodic dissolved oxygen feast‐famine cycles in a scale‐down system

Dissolved-oxygen feedback control fermentation for enhancing β-carotene in engineered Yarrowia lipolytica

Dissolved oxygen alters the microbial interactions of anammox consortia in PN/A process

Effect of Oxygen Limitation and Medium Composition on Escherichia coli Fermentation in Shake‐Flask Cultures

Oxygen Transfer Effect on the Growth of Limosilactobacillus reuteri ATCC 53608 and on Its Metabolic Capacity

Oxygen transfer rate control in the production of human-like collagen by recombinant Escherichia coli

Batch fermentation kinetics of acetoin produced by Bacillus subtilis HB-32

Influence of oxygen partial pressure on homoacetogenesis and promotion of acetic acid accumulation through low pH regulation under microaerobic conditions