Abstract:Summary Concentrated monosodium glutamate wastewater (CMGW) generated from the production of monosodium glutamate is an organic wastewater with high concentration of ammonia,chemical oxygen demand, biochemical oxygen demand and SO2-4 and low pH. Discharge of CMGW has raised serious environmental problems,and potential secondary pollution existed even treated with traditional physical and chemical processes. It has already been reported that the richness of nitrogen and carbon makes the recycling of this wastewater possible in the way of microbial fermentation as medium.However,the differences of strain and fermentation purpose require that the medium contains different nutritional compositions with a certain dosage.Bacillus subtilis F-2,isolated from a commercial organic fertilizer,can inhibit the growth of 18 plant pathogenic fungi with varying degrees,especially in F.oxysoporum f.sp niweum with inhibition rate of 93%,which reveal the potential to prepare bio-organic fertilizer under biocontrol.In addition,F-2 also plays an important role in decomposition of organic waste.The study on degradation of food waste has pointed to its dominance in microbial community. Therefore,F-2 as a prospective functional bacteria in agriculture and environment,it is necessary to improve F-2 viable cell production as much as possible.Massive studies were focused on medium optimization of B.subtilis to enhance its cell density in fermentation liquor.However,the main ingredients of medium used in most of these studies were peptone,yeast extracts,beef extracts,soy or corn flour,associated with great cost and excessive consumption of resources. The purpose of this study was to investigate a cost-effective resource utilization of CMGW by increasing the density of B. subtilis F-2 viable cells in cultures. The CMGW medium which was 80-fold diluent of the wastewater,i.e.,12.5 g/L CMGW,was served as the main carbon and nitrogen sources of strain F-2.Contrast experiments of shaking cultures,orthogonal and single factor experiments were applied to find the optimal CMGW medium formula and its culturing condition. The contrast experiments showed that the D(600 nm) value of F-2 suspension and viable cell density of the CMGW medium was significantly higher than that of nutrient broth(NB) medium,and the amino acid content in the CMGW medium decreased significantly after culturing.The optimal formula identifying F-2 by the orthogonal experiment of L1 6(4 3 ×2 6) was as follows:12.5 g/L CMGW,1.0 g/L beef extracts,4.0 g/L peptone,0.5 g/L MnSO4 ·2 H 2 O,0.02 g/L H 3 BO3 ,0.1 g/L FeSO4 ·7 H 2 O and 0.5 g/L MgSO4 ·7 H 2 O.The viable cell density in the optimized CMGW medium was 2.9 and 6.3 times of the CMGW medium and NB medium,respectively. Furthermore,according to the results of single factor experiment,the proper initial pH and culturing temperature of the optimized CMGW medium were screened as pH 6.5 7.5 and 30 35 ℃. In conclusion,the CMGW medium is an ideal substitute for NB medium in the fermentation of B.subtilis F-2,providing a practicable and promising approach to reuse and recover CMGW.Moreover,the CMGW medium is superior to NB medium,and the fermentation effect is even better after the medium and culturing condition are optimized.

Research Progress on the Low-cost Preparation of Microbial Flocculants

The Development and Application of Flocculants

Unraveling the Potential of Microbial Flocculants: Preparation, Performance, and Applications in Wastewater Treatment

Optimization of a Culture Medium for Bacillus Subtilis Based on Monosodium Glutamate Wastewater

Study on the Application of Microbial Flocculant in Water Treatment

Experimental Research on Handling the Middle Phase Wastewater in Paper Making Process by Bio-flocculant

Preparation and Application of Microbial Flocculant

Preparation of Microbial Flocculant MF-1 and Its Flocculation on Midcourse Wastewater in Papermaking Factory

Research progress on chemical flocculation in pharmaceutical wastewater treatment

Production of Bioflocculants Prepared from Wastewater Supernatant of Anaerobic Co-Digestion of Corn Straw and Molasses Wastewater Treatment

Growth rates and doubling times of posterior uveal melanomas.

Preparation of a bacterial flocculant by using caprolactam as a sole substrate and its application in amoxicillin removal

STUDY OF FLOCCULATING MECHANISM OF MICROBIAL FLOCCULANT MBFA9

A novel bioflocculant produced by Klebsiella sp. and its application to sludge dewatering

Bioflocculants’ Production in a Biomass-Degrading Bacterium Using Untreated Corn Stover As Carbon Source and Use of Bioflocculants for Microalgae Harvest

Effects of Culture Time on the Production of Bioflocculants

A review on production of lignin-based flocculants: Sustainable feedstock and low carbon footprint applications

Optimization and Characterization of Polysaccharide-Based Bioflocculant Produced by Paenibacillus Elgii B69 and Its Application in Wastewater Treatment

Study of Efficient Bioflocculant Produced by a Bacillus Strain

A novel polysaccharide-based bioflocculant produced by Bacillus subtilis 35A and its application in the treatment of dye decolorization, heavy metal ion adsorption and meat product wastewater

Bioflocculant BF-R1 Production by Bacillus Sp. R1 Using Wheat Bran Hydrolysate and Its Application in Wastewater Treatment