Abstract:In order to study the influence of smooth heater size on the performance of pool boiling heat transfer, saturated boiling experiments of FC-72 were conducted on eight sized smooth silicon chips (the test surfaces are denoted as S5 similar to S30, and their dimensionless dimensions are in the range of L-h/L-c = 7 similar to 42). The bubble dynamics during boiling were observed with a high-speed camera. The results indicated that in natural convection regime, the heat transfer coefficient decreases with increasing heater size at a given heat flux. Besides, the larger surfaces enter into the nucleate boiling regime earlier. In a fully developed nucleate boiling regime, S5 surface displays the optimal heat transfer performance. The reality is that no vapor columns are produced even in the high heat flux range due to its small bubble departure diameter and high bubble departure frequency. For S8 similar to S15 surfaces, the wall temperatures increase continuously with the increase of heat flux, while S20 similar to S30 surfaces present a trend of first keeping constant and then increasing. The active nucleation site densities on S15 similar to S30 surfaces follow the law of N-a = 0.45q(2) in the whole nucleate boiling regime. By contrast, for S5 similar to S12 surfaces, the nucleation site densities abide by this law only in a fully developed nucleate boiling regime. In addition, the departure diameter and departure frequency of bubbles increase with the increase of heat flux for all surfaces. It is observed that with the increase of smooth heater size, CHF presents a changing trend of first increasing (in range of L-h <= lambda(D), lambda(D) is the most dangerous Taylor wavelength), then decreasing (in range of lambda(D) < L-h <= 3 lambda(D)) and finally leveling off (in range of L-h > 3 lambda(D)). Accordingly, the CHF value maximizes at the heater size L-h = lambda(D). In the segment of decreased CHF, the decline rate of CHF in range of lambda(D) < L-h <= 2 lambda(D) is larger than that in range of 2 lambda(D) < L-h <= 3 lambda(D). Meanwhile, the influencing mechanisms of heater size on CHF were explained by consideration into bubble patterns and behavior.

Subcooled Pool Boiling of Water on a Downward-Facing Stainless Steel Disk in a Gap

Subcooled Pool Film Boiling Heat Transfer from Spheres with Superhydrophobic Surfaces: an Experimental Study

A Review of Pool-Boiling Processes Based on Bubble-Dynamics Parameters

Experimental Study on Pool Transition Boiling with Downward Facing Heated Surface

Experimental Study of Flow Boiling Instabilities in Horizontal Tubes under Gas–liquid Stratification Condition: Effects of Heat Flux and Inlet Subcooling Degree

Two-dimensional Mesoscale Simulations of Saturated Pool Boiling from Rough Surfaces. Part II: Bubble Interactions above Multi-Cavities

Lattice Boltzmann Modeling of Pool Boiling with Large Liquid-Gas Density Ratio

Subcooled pool boiling performance on conical micro-pillars structures surfaces

Subcooled Flow Boiling On Micro-Porous Structured Copper Surface In A Vertical Mini-Gap Channel

Numerical Study on Bubble Behaviour and Heat Transfer Characteristics of Subcooled Pool Boiling Based on Non-Empirical Boiling and Condensation Model

Experimental Study of Pool Boiling Heat Transfer on Novel Bistructured Surfaces Based on Micro-Pin-finned Structure

Numerical Study on Bubble Departing Behavior from Heated Surface in Subcooled Pool Boiling

The Influence of Subcooling on Nucleate Boiling Heat Transfer in an Immersed Confined Space

Experimental investigation of boiling in rectangular narrow space

Experimental study of bubble behaviors and heat transfer coefficient on hot steel balls during deionized water pool boiling

Influence of Smooth Heater Size on Critical Heat Flux and Heat Transfer Coefficient of Saturated Pool Boiling Heat Transfer

Experimental correlation for pool boiling heat transfer on metallic foam surface and bubble cluster growth behavior on grooved array foam surface

Dry Spot Dynamics and Wet Area Fractions in Pool Boiling on Micro-Pillar and Micro-Cavity Hydrophilic Heaters: A 3D Lattice Boltzmann Phase-Change Study

Investigation on Heat Transfer of In-Tube Supercritical Water Cooling Accompanying Out-Tube Pool Boiling

Experimental study of subcooled boiling pool heat transfer and its “hook back” phenomenon on micro/nanostructured surfaces

Experimental Investigation of Pool Boiling Heat Transfer on the Radial Micro-Pillar Surfaces