Abstract:Carbon emissions have become a prominent global concern, with the utilization of fossil fuels serving as the primary contributor. Ammonia, being a hydrogen carrier without carbon, has the potential to be utilized through combustion, resulting in the production of water and nitrogen as ideal byproducts, which are environmentally benign. However, individual ammonia is difficult to combust due to its unfavorable combustion characteristics. Hence, ammonia needs to be blended with other fuels that possess superior combustion characteristics. Additionally, NH 3 inherently contains a significant amount of nitrogen, a fuel element that can contribute to the increased release of NO x emissions. In this work, a simulation was conducted using CHEMKIN to investigate the nitrogen transformation characteristics during ammonia/coal co-firing under deeply air-staged combustion. Experimental studies primarily focus on macroscopic factors, such as temperature and pressure, while often neglecting the analysis of reaction mechanisms. The utilization of the chemical reaction kinetics simulation method can provide valuable insights into the reactions and substances that exert the most significant impact on the formation of NO x , as well as elucidate the pathway of fuel-nitrogen conversion during combustion. Simulation results demonstrate that as the NH 3 co-firing ratio (CR-NH 3 ) increases, the volume content of NO x initially rises, reaching its peak at approximately 10% CR-NH 3 , and subsequently declines. The conversion rate of NO x increases as the combustion temperature in the primary combustion area rises. The primary reactions have a greater influence on the formation of NO at low-temperature conditions. However, it is important to note that low temperature also decreases the combustion efficiency. The incorporation of overfire air (OFA) in advance has the potential to mitigate nitrogen reduction in the primary combustion area, while simultaneously improving NO x emissions. With the oxygen concentration of primary air increased, the conversion rate of NO x gradually decreases. It undergoes a sharp change before reaching 21% oxygen concentration, after which it levels off. In addition, high oxygen concentration increases the pathway of NO consumption. When the excess air coefficient of OFA falls within the range of 0.35–0.45, the NO x conversion rate can be minimized. The present study aims to offer technical assistance and guidance for effectively controlling NO x emissions in ammonia/coal co-firing boilers.

Comparison of Nitrogen Oxide Emissions from Boilers for a Wide Range of Coal Qualities

Low NO_x Combustion Tests on a 200MW Coal-Water Slurry Fired Boiler

Experiment and Numerical Simulation Study of Low-nitrogen Combustion Technology inside Small Gas Boiler

Research on Full Premixed Combustion and Emission Characteristics of Non-Electric Gas Boiler

EXPERIMENTAL STUDY ON THE PROPERTY OF Nox EMISSION IN HIGH TEMPERATURE COMBUSTION OF COMMONLY USED COAL SORTS AND THEIR MIXTURES IN LARGE-SCALE TANGENTIALLY FIRING PULVERIZED COAL BOILERS

NOx Emission Characteristics of Coal and Biomass Co-firing in O2/CO2 Atmosphere

NOx Emission and Its Control in Utility Coal-fired Boilers in China

CHARACTERISTICS OF NOX EMISSION AND REMOVAL FOR COAL FIRED UTILITY BOILER

Experimental study on combustion and NOx emission characteristics of Zhehun blended coal

Experimental Research on the Combustion and NO_x Generation Characteristics of Low Volatile Coal

Simulation study on nitrogen transformation characteristics of NH 3 /Coal Co-firing under deeply air-staged condition

Investigations on combustion optimization and NOX reduction of a 600-MWe down-fired boiler: Influence of rearrangement of tertiary air and jet angle of secondary air and separated over-fire air

Experimental study on NOx emission characteristics under oxy-fuel combustion

Industrial measurement of combustion and NOx formation characteristics on a low-grade coal-fired 600MWe FW down-fired boiler retrofitted with novel low-load stable combustion technology

Industrial scale testing on the combustion and NO emission characteristics of ammonia cofiring in a 40 MWth coal-fired boiler

Experimental Study on the Influence of Operating Parameters on NOx and N2O Emissions During Co-Firing of NH3 and Coal in a CFB

Combustion and NOx Emission Behavior of Chinese Coals

Study on Low NOx Optimimal Operation of a Tangentially Fired Boiler under Variable Parameters

Characteristics of Combustion and NOx Emission in a 600 MWe Wall-Fired Boiler Under Varying Coal Mill and Burner Damper Configurations

Research on Oxy-Fuel Combustion Characteristics of Two Typical Chinese Coals

Industrial experimental study on combustion characteristics and NOx emission characteristics of a 600 MWe wall‐fired boiler under ultra‐low excess air coefficient conditions