Abstract:The extraction of an essential oil from discarded tobacco leaves using a combination of solvent extraction and steam distillation (SE–SD) was investigated. The effect of different parameters, such as temperature, extraction time and liquid–solid ratio, on the extraction yield was investigated using the Response Surface Method (RSM) with the Box–Behnken Design (BBD) method. The temperature and liquid–solid ratio were found to have a significant effect on the yield of extract (oleoresin). A yield of 3.38±0.03% of the oleoresin (final essential oil yield was 0.89%) could be extracted under the following optimized conditions: a temperature of 41°C, a liquid–solid ratio of 6.27mL/g and a time of 5h. Composition and characteristics of the discarded tobacco essential oils and oleoresins obtained by SE–SD, hydrodistillation and solvent extraction were analyzed by gas chromatography/mass spectrometric detection, to allow the extraction methods to be compared. The results showed that the same compounds were largely present in the different tobacco essential oils, but their relative concentrations differed. General characteristics of the extracts obtained from the three extraction methods showed that the SE–SD essential oil was of better quality and therefore of higher value. Thus, SE–SD is the optimum process for the extraction of high quality essential oil from discarded tobacco.

Extraction of Nicotine in Tobacco with Ultrasonic Supercritical CO2 Fluid

Optimization of Process Parameters of Extraction of Amentoflavone, Quercetin and Ginkgetin from Taxus Chinensis Using Supercritical CO2 Plus Co-Solvent.

Extraction Technology of Tobacco Absolute Oil by Compound Solvent

Extraction of Solanesol from Tobacco with Supercritical Carbon Dioxide

Extraction and Purification of Nicotine from Tobacco Rhizomes by Supercritical CO2

Separation Of 5,8,11,14,17-Eicodapentaenoic Acid And 4,7,10,13,16,19-Docosahemanoic Acid By Supercritical Fluid Chromatography

The Study of Supercritical CO2 Extraction of Artemisinin

Study on Retention Factor and Resolution of Tocopherols by Supercritical Fluid Chromatography.

Research of Extraction Tobacoo Essential Oils by Ultrasonic-Assisted Method

Supercritical Carbon Dioxide Extraction in Membrane Formation by Thermally Induced Phase Separation

Study on Extraction of Catechin from Catechu by Ultrasonic Technology

Separation Of Tocopherol Homologues By Supercritical Fluid Chromatography

Extraction and separation process of chlorogenic acid from tobacco residue

Extraction and Purification of Solanesol from Tobacco(i). Extraction and Silica Gel Column Chromatography Separation of Solanesol

Effects of moisture content in cigar tobacco on nicotine extraction. Similarity between soxhlet and focused open-vessel microwave-assisted techniques

Decaffeination of Green Tea by Supercritical Carbon Dioxide

Separation and purification of active ingredients in tobacco by free flow electrophoresis

Extraction of Essential Oil from Discarded Tobacco Leaves by Solvent Extraction and Steam Distillation, and Identification of Its Chemical Composition

Analysis on Extraction Behaviour of Lithium-ion Battery Electrolyte Solvents in Supercritical CO2 by Gas Chromatography

Optimization of Ultrasonic-Assisted Extraction of Chlorogenic Acid from Tobacco Waste

Supercritical CO2 Fluid Extraction of Diosgenin from Dioscorea Zingiberensis