Abstract:A series of Ni-SiO2 aerogel and xerogel catalysts were prepared by sol-gel supercritical drying (SCD) and general drying methods using tetraethylorthosilicate (TEOS) as a precursor of silica and nickel nitrate as starting material of nickel. Water or alcohol was used as solvent. Based on the experimental results of nitrogen adsorption-desorption, XRD, temperature-programmed reduction (TPR), IR, temperature-programmed desorption of hydrogen (H-2-TPD) and activity evaluation, the physical and chemical properties and catalytic performance of the catalysts for hydrogenation of m-dinitrobenzene to m-phenylenediamine were investigated. Both the Ni-SiO2 aerogel catalysts had high specific surface areas, but their catalytic activity and selectivity were low due to their small active surface areas caused by sintering of nickel crystallite. For the Ni-SiO2 xerogel catalyst that used alcohol as solvent, well-dispersed nickel particles were formed, but the strong interaction between nickel and the support made the catalyst difficult to be reduced, thus resulting in lower degree of the utilization of metal. However, the xerogel catalyst that made use of water solution exhibited the highest catalytic activity and selectivity for m-phenylenediamine attributed to its higher surface area of active nickel, over which the conversion of m-dinitrobenzene and the yield of m-phenylenediamine were up to 92.6% and 88.4%, respectively, under the conditions of 2.6 MPa and 373 K after reaction for 1 h.

Hydrogenation of Naphthalene on Nickel Phosphide Supported on Silica

Synthesis of m-phenylenediamine from m-dinitrobenzene over silica-supported nickel catalyst

Sol-Gel Preparation, Characterization and Hydrogenation Property of Silica Supported Ni Catalyst

Study on the Ni Supported Catalysts Used for Hydrogenation of IPN to Produce MXDA

Hydrogenation of M-Dinitrobenzene to M-Phenylenediamine over La2o3-Promoted Ni/Sio2 Catalysts

Selective Hydrogenation of Phthalic Anhydride to Phthalide over Supported Nickel Catalysts

Preparation of Ni/SiO<sub>2</sub> catalyst in ionic liquids for hydrogenation

Preparation of Ni/SiO 2 catalyst in ionic liquids for hydrogenation

Liquid-Phase Hydrogenation of Nitrobenzene over Ag-Ni Bimetallic Catalysts Prepared by Adsorption Phase Synthesis

Selective Hydrogenation of Naphthalene over γ-Al2O3-Supported NiCu and NiZn Bimetal Catalysts

Effects of preparation conditions for Ni/γ-Al2O3 catalyst on saturated hydrogenation of naphthalene

Hydrogenation of Model Compounds Catalyzed by Mcm-41-Supported Nickel Phosphide

Hydrogenation of Nitrobenzene to Aniline over Silica Gel Supported Nickel Catalysts

Comparative Study on the Hydrogenation of Naphthalene over Both Al2O3-Supported Pd and NiMo Catalysts against a Novel LDH-Derived Ni-MMO-Supported Mo Catalyst

Deep Hydrogenation Saturation of Naphthalene Facilitated by Enhanced Adsorption of the Reactants on Micro‐Mesoporous Pd/HY

HYDROGENATION PROPERTIES OF Mo-Ni-P CATALYST ON MCM-41 SUPPORTED

A highly loaded and dispersed Ni2P/SiO2 catalyst for the hydrotreating reactions

Tuning the mesopore-acid-metal balance in Pd/HY for efficient deep hydrogenation saturation of naphthalene

Highly active Ni 2 P/SiO 2 catalysts phosphorized by triphenylphosphine in liquid phase for the hydrotreating reactions

Effect of Supports on the Supported Ni2P Catalysts Prepared by the Phosphidation Using Triphenylphosphine in Liquid Phase

Hierarchical porous Pt/Hβ catalyst with controllable acidity for efficient hydrogenation of naphthalene