Abstract:We have studied the microphase phase separation behavior of a series of rod-coil diblock copolymers with poly(2,5-bis[4-methoxyphenyl]oxycarbonyl)styrene) (PMPCS) as the rod and poly(epsilon-caprolactone) (PCL) as the coil. PMPCS is a typical mesogen-jacketed liquid crystalline polymer, of which the hexatic columnar nematic (Phi(HN)) phase can develop from the amorphous state upon heating irreversibly once the chain conformation becomes extended. It is found that the PCL-b-PMPCS samples with amorphous PMPCS behave similar to the coil-coil diblock copolymer, with the microphase separated morphology mainly determined by the volume fraction of PMPCS (f(PMPCS)). At the temperature above the glass transition temperature of PMPCS (similar to 116 degrees C), the transition from amorphous phase to Phi(HN) phase of PMPCS blocks occurs. This induces the "order-order" and/or "disorder-order" transition of the phase morphology, resulting in the lamellar morphology existing in a wide range of f(PMPCS) from 40% to 80%. In this case, PCL-b-PMPCS presents the typical feature of rod-coil diblock copolymer. Using one-dimensional correlation function to analyze the small-angle X-ray scattering data measured at 200 degrees C, we obtained the thicknesse of PMPCS and PCL domain (L-PMPCS and L-PCL) in the lamellar structures. A linear relationship is identified, L-PMPCS = 0.2N(PMPCS) (nm), with N-PMPCS as the degree of polymerization of PMPCS block. As the chain axis of PMPCS block is parallel to the normal of the lamellae, we conclude that the diblocks form a "single-layer smectic A" lamellar phase, and more importantly, L-PMPCS is the extended chain length of PMPCS block, which can be well controlled by polymerization. For PCL block, a scaling of L-PCL similar to N-PCL(0.85) (N-PCL is the degree of polymerization of PCL block) is observed, indicating that the molten PCL block is highly stretched. We further estimated the interfacial area per rod-like PMPCS (S/X) in the lamellar phase, which is always smaller than the cross section area of PMPCS rod in the Phi(HN) phase. Combining with the liquid crystallinity of samples measured by wide-angle X-ray diffraction, we consider that the variation of S/X reflects that, near the PMPCS/PCL interface, the PMPCS segments are not packed in Phi(HN) phase. This is mainly due to the strong segregation between the molten PCL and the liquid crystalline PMPCS which can cause the PMPCS blocks to be further stretched. For a fixed N-PCL, the smaller S/X is, the larger L-PCL is. However, a linear relationship of L-PCL(S/X) = 0.21N(PCL) (nm(3)) can be realized, wherein the value of slope is the volume of PCL repeating unit.

Order-order transition induced by mesophase formation in a novel type of diblock copolymers based on poly(isobutyl methacrylate) and poly[2,5-di(isopropyloxycarbonyl)styrene]

Self-assembly of Cyclic Rod-Coil Diblock Copolymers

Thermoreversible Order–Order Transition of a Diblock Copolymer Induced by the Unusual Coil–Rod Conformational Change of One Block

Thermoreversible Order−Order Transition of a Triblock Copolymer Containing a Mesogen‐Jacketed Liquid Crystalline Polymer with a Re‐Entrant Phase Behavior

Remarkably Rich Variety of Nanostructures and Order–Order Transitions in a Rod–Coil Diblock Copolymer

Order−Order Transition in a Rod−Coil Diblock Copolymer Induced by Supercritical CO2

Lamellar Phase of Rod-Coil Diblock Copolymer Based on Mesogen-jacketed Liquid Crystalline Polymer: A Study of Chain Stretching

Design, Synthesis, And Multiple Hierarchical Ordering Of A Novel Side-Chain Liquid Crystalline-Rod Diblock Copolymer

Synthesis and Self-Assembly of A Linear Coil-Coil-Rod Abc Triblock Copolymer

PAA-b-PPO-b-PAA Triblock Copolymers with Enhanced Phase Separation and Inverse Order-to-order Phase Transition Upon Increasing Temperature

Microphase Separation Facilitating and Stabilizing Hierarchical Segment Self-Assembly of Combined Main-Chain/Side-Chain Liquid Crystalline Polymer in Diblock Copolymer

Influence of liquid crystalline formation on the phase behavior of side-chain liquid crystalline block copolymers

Interplay Between the Thermotropic Mesomorphic Behavior and the Microphase Separation in Dendron–liquid Crystalline Block Copolymers

Hierarchical Assembly of A Series of Rod-Coil Block Copolymers: Supramolecular Lc Phase in Nanoenviroment

Transition Paths of Ordered Phases in a Diblock Copolymer under Cylindrical Confinement

Order-Order Transitions Of Diblock Copolymer Melts Under Cylindrical Confinement

Lamella-to-Lamella Transition and Effect of Coil-Stretching on Crystallization in a Rod−Coil Diblock Copolymer Containing Poly(ϵ-caprolactone)

New Morphologies and Phase Transitions of Rod–Coil Dendritic–Linear Block Copolymers Depending on Dendron Generation and Preparation Procedure

Cylinder-gyroid-lamella Transitions in Diblock Copolymer Solutions: a Simulated Annealing Study.

Cylindrical to Lamellar Microdomain Transition Upon Heating for a Linear Tetrablock Copolymer with Upper Critical Ordering Transition

Synthesis and Characterization of Novel Rod–coil Diblock Copolymers of Poly(methyl Methacrylate) and Liquid Crystalline Segments of Poly(2,5‐bis[(4‐methoxyphenyl)oxycarbonyl] Styrene)