Abstract:Upflow anaerobic sludge blanket (UASB) reactor that was seeded with anaerobic sludge acclimated to chlorophenols was used to investigate the feasibility of anaerobic biotreatment of synthetic wastewater containing pentachlorophenol (PCP) with additional sucrose as carbon source. Two sets of UASB reactors were operated at one time. But the seeded sludge for the two reactors was different and Reactor I was seeded with the sludge that was acclimated to PCP completely for half a year, and Reactor II was seeded with the mixed sludge that was acclimated for half a year to PCP, 4-CP, 3-CP or 2-CP, respectively. The degradation of PCP and the operation fee treating the wastewater are affected by the concentration of MEDS (microorganism easily degradable substrate). So the confirmation of the suitable ratio of [COD] and [PCP] was the key factor of treating the wastewater containing PCP economically and efficiently. During the experiment, the synthetic wastewater with 180.0mgL−1 PCP and 1250–10000mgL−1 COD could be treated steadily in the experimental Reactor I. The removal efficiency of PCP was more than 99.5% and the removal efficiency of COD was up to 90%. [PCP] (concentration of PCP) in effluent was less than 0.5mgL−1. [PCP] in influent could affect proper [COD] (concentration of COD) range in influent that was required for maintenance of steady running of the experimental reactor with a hydraulic retention time (HRT) from 20 to 22h. [PCP] in influent would directly affect the necessary [COD] in influent when the UASB reactor ran normally and treated the wastewater containing PCP. When [PCP] was 100.4, 151.6 and 180.8mgL−1 in influent, respectively, [COD] in influent had to be controlled about 1250–7500, 2500–5000 and 5000mgL−1 to maintain the UASB reactor steady running normally and contemporarily ensure that [COD] and [PCP] in effluent were less than 300 and 0.5mgL−1, respectively. With the increase of [PCP] in influent, the range of variation of [COD] in influent endured by the UASB reactor was decreasing. The ratios of [COD] and [PCP] in influent could affect removal efficiency of PCP and COD, the concentration of total volatile fatty acids (VFA) in effluent, biogas quantity and methane content in biogas. [PCP] in influent was linearly or semi-logarithmically correlated to [COD] in effluent when [COD] in influent was 5750±250mgL−1, and so was the relationship between [COD] in influent and [PCP] in effluent when [PCP] in influent was 100.4 or 151.6mgL−1, less than the maximum permissible [PCP]. The sources of seeded sludge, the way of sludge acclimation and the characteristics of anaerobic sludge could all affect the UASB reactor capacity treating PCP. When [PCP] were less than 180.8mgL−1 for Reactor I and 151.6mgL−1 for Reactor II, the variation of [PCP] in influent had little effect on the UASB reactor volume gas production rate and substrate gas production rate. And [VFA] and pH value in effluent were affected a little. Volume biogas production rate and substrate biogas production rate of the UASB reactor were only affected by [COD] and loading rate in influent. But when [PCP] was more than 151.6mgL−1 for Reactor II, the biogas production fell quickly and was over 3 days later. [VFA] in effluent from Reactor II increased up to 2198.1mgL−1 quickly and the pH value fell to less than 7. Reactor II could not run normally. The component of VFA accumulated quickly was mainly acetate (above 50%). With [PCP] increased from 7.9 to 180.8mgL−1 gradually in influent, the methane content in biogas from Reactor II decreased from 70% to 60%, but the reactor could still run normally. Then as for Reactor II, the content of methane have fallen from 75% to 45% or so quickly. And Reactor II could not run steadily. So the conclusion could be drown that too high [PCP] in influent for UASB reactor mainly inhibited the activity of methane-producing bacteria cultures utilizing the acetate.

Effect of Wastewater Composition on the Calcium Carbonate Precipitation in Upflow Anaerobic Sludge Blanket Reactors

Calcium carbonate precipitation in UASB reactors with different substrates

Effect of Easily Degradable Substrate on Anaerobic Degradation of Pentachlorophenol in an Upflow Anaerobic Sludge Blanket (UASB) Reactor

Effect of Pentachlorophenol and Chemical Oxygen Demand Mass Concentrations in Influent on Operational Behaviors of Upflow Anaerobic Sludge Blanket (UASB) Reactor.

Improved stability of up-flow anaerobic sludge blanket reactor treating starch wastewater by pre-acidification: Impact on microbial community and metabolic dynamics

The Effect of Calcium on the Treatment of Fresh Leachate in an Expanded Granular Sludge Bed Bioreactor

Effect of Calcium Ions on Dewaterability of Enzymatic-Enhanced Anaerobic Digestion Sludge

Anaerobic granular sludge performance in an expanded granular sludge bed reactor treating calcium-rich wastewater by adjusting CaCO 3 crystallization: Effect of upflow velocity and Ca 2+ concentration

The culprit for the declining performance of anaerobic reactors caused by calcification: Bioavailability deterioration

Uncover the secret of granule calcification and deactivation in up-flow anaerobic sludge bed (UASB) reactor with long-term exposure to high calcium

Performance of High-Loaded Anammox Uasb Reactors Containing Granular Sludge

The Roles Of Calcium In Sludge Granulation During Uasb Reactor Start-Up

Review of the mechanism and control methods of anaerobic granular sludge calcification

Response of Methanogens in Calcified Anaerobic Granular Sludge: Effect of Different Calcium Levels.

Anaerobic granule development for removal of pentachlorophenol in an upflow anaerobic sludge blanket (UASB) reactor

Calcium Precipitate Induced Aerobic Granulation

Role of sulfate in regulating performance and metabolic mechanisms of bioelectrochemical up-flow anaerobic sludge blanket fed with methanolic wastewater

Strategy to prevent calcification by restricting surface adhesion of Ca2+: Reduced affinity of extracellular polymeric substances for Ca2+ by mild acidic conditions

Post-treatment of anaerobically pre-treated molasses wastewater in an aerobic granular sludge sequencing batch reactor

The effect of Fenton sludge on anaerobic digestion of papermaking wastewater in an upflow anaerobic sludge blanket reactor

Deciphering the effect of sodium dodecylbenzene sulfonate on up-flow anaerobic sludge blanket treatment of synthetic sulfate-containing wastewater