Abstract:Pressurized oxy-fuel combustion (POFC) is currently considered one of the advanced coal utilization technologies for large-scale CO2 capture but causes distinct coal conversion behavior, particularly more complicated and unclear with wet recycle. To explore coal conversion mechanisms and structural evolution of chars during the initial stage of POFC, lignite devolatilization was conducted in an isothermal horizontal tube furnace at 900 degrees C in individual and blending CO2 and H2O atmospheres (CO2/N2, H2O/N2, and H2O/CO2) under different pressures of 0.1 to 0.9 Mpa. The pore and chemical structures of resulting chars were characterized using N2 adsorption and Raman spectroscopy, and oxy-fuel combustion reactivities of chars were evaluated by thermogravimetry. The results indicate that coal char conversion in coexisting H2O/CO2 presents three different interactions of addition, synergy, and inhibition, corresponding to mesoporous surface area evolution of chars with partial and total pressures of H2O. CO2 chars primarily consist of micropores while chars formed in H2O-rich atmospheres contain more mesopores. These dominant micro-/mesopore numbers increase with CO2/H2O concentrations but decrease at 0.9 Mpa. The accelerated condensation of aromatic rings in chars induced by CO2 and H2O gasification also follows different pathways. H2O gasification dominates the carbon skeleton structure evolution of H2O/CO2 chars but the interaction between H2O/CO2 results in the complex variations of O-containing structures. CO2/N2 chars have the highest oxy-fuel combustion reactivities, follow by H2O/CO2 chars, and H2O/N2 char reactivities are the lowest. The combustion reactivities of H2O/CO2 chars show a more obvious attenuation trend than that of H2O/N2 chars and the disparities narrow with H2O concentration. Elevated total pressure decreases the reactivities of all chars along with the growth of aromatic ring sizes. The correlations between oxy-combustion reactivities and Raman band area ratios highlight the significance of the devolatilization stage to subsequent char combustion.

PRELIMINARY STUDY ON OXYGEN ELIMINATION IN SHENGLI LIGNITE DURING LIQUEFACTION PREREACTION

Characterization of Oxygenates, Nitrogenates, and Sulfonates in Shengli Lignite Extracts by Orbitrap Mass Spectrometry

Effect of CO2/H2O on the Incipient Ultrafine Particulate Matter Formation in Oxy-fuel Combustion of High-Sodium Lignite

A Preliminary Investigation of CO Effects on Lignite Liquefaction Process

Oxidation of Shengli Lignite with Aqueous Sodium Hypochlorite Promoted by Pretreatment with Aqueous Hydrogen Peroxide

Experiment Study on Supercritical Methanol Affected to Pre-treatment of Lignite Liquefaction

Deoxygenation effect on hydrophilicity changes of Shengli lignite during pressurized pyrolysis at low temperature

STUDY ON SUPERCRITICAL METHANOL TREATMENT TO REMOVE OXIDE FROM LIGNITE

Molecular characteristics of the oxidation products of a lignite based on the big data obtained from Fourier transform ion cyclotron resonance mass spectrometry

Gasification characteristics and thermodynamic analysis of ultra-lean oxygen oxidized lignite residues

Study on oxygen species in the products of co-liquefaction of coal and petroleum residues

Comparative Study of the Catalytic Performances of Na2CO3 and Γ-Feooh in Hydroliquefaction to Propose a Two-Stage Lignite Catalytic Liquefaction Process

Experimental Study on Devolatilization Characteristics of Lignite During Pressurized Oxy-Fuel Combustion: Effects of CO2 and H2O

Mass Spectrometric Evaluation of the Catalytic Deoxygenation of Soluble Organic Matter in Xiaolongtan Lignite

Thermal treatment of Shengli lignite and subsequent oxidation

Shengli Lignite Liquefaction under Syngas and Complex Solvent

Study on the relationship between pyrolysis volatile products and structure of Shengli lignite using TG-FTIR-GC/MS

Transition of oxygenic functional groups in lignite during the process of oxidation

Study On Photooxidation And Biodegradation Of Lignite

Investigation into the Relationship Between Oxygen-Containing Groups and the Release of Na and Cl During Preoxidation and Pyrolysis of Na-Enriched Zhundong Coal

A Study on the Hydro-Liquefaction Kinetics of Shengli Lignite During the Heating-Up and Isothermal Stages under Mild Conditions