Abstract:An entrapped mixed microbial cell (EMMC) process was investigated for simultaneous removal of carbon and nitrogen from a synthetic wastewater in a single bioreactor. The influent had a soluble chemical oxygen demand (SCOD)/nitrogen ratio varying from 4 to 15 and an alkalinity of 140 and 230 mg/L as calcium carbonate. An alternating schedule of intermittent aeration was used for two sizes of carriers: 10 X 10 X 10 mm(3) and 20 X 20 X 20 mm3. The medium carrier (10 X 10 X 10 mm3) was found to achieve higher removals of nitrogen, chemical oxygen demand, and 5-day biochemical oxygen demand of 92, 95, and 97%, respectively. These higher removal rates occurred at a 12-hour hydraulic retention time (HRT), an aeration/ nonaeration ratio of 0.5:2 hours, and an SCOD/nitrogen ratio of 15 in the influent. Influent alkalinity concentrations of 140 and 230 mg/L as calcium carbonate were found to have minimum effect on the removal of carbon and nitrogen. However, the oxidation-reduction potential, ranging from -100 to 400 mV (during air-off period), provides better nitrogen removal efficiency to maintain the total nitrogen (nitrate, nitrite, and ammonium) less than 10 mg/L when an SCOD/nitrogen ratio of 10 or 15 is maintained in the influent. Nitrogen removal efficiency increased with increasing ratios of SCOD/nitrogen in the influent (i.e., SCOD/ nitrogen ratio of 15 > 10 > 7 > 4.0). The results of actual wastewater operation based on a study of synthetic wastewater show that organics removal efficiencies (94.6 and 94.2%) and nitrogen removal efficiencies (61.0 and 60.9%) are similar for reactors packed with medium and large carriers, respectively, when they are operated with a 9-hour HRT, an air on/air off ratio of I hour:2 hours and an SCOD/nitrogen ratio of 4.6.

Nitrogen removal of the secondary effluent by embedded immobilized bacteria in moving-bed

Performance of System Consisting of Vertical Flow Trickling Filter and Horizontal Flow Multi-Soil-Layering Reactor for Treatment of Rural Wastewater

Tubular reactor-enhanced ecological floating bed achieves high nitrogen removal from secondary effluents of wastewater treatment

Nitrogen Biological Removal for Anaerobic Membrane Bioreactor Effluent

Research on Advanced Treatment of Effluent from Wastewater Treatment Plant by Embedded Immobilized Bacteria

[Nitrogen Removal Performance and Microbial Community Analysis of Activated Sludge Immobilization].

TREATMENT OF MUNICIPAL WASTEWATER WITH LOW CARBON AND HIGH NITROGEN & PHOSPHORUS CONTENT

Nitrogen Removal by Immobilized Purified Indigenous Bacteria in Fluidized Bed

Study on Treatment of Micro-polluted Raw Water Using Embedded Immobilized Nitrobacteria

Nitrifying Treatment of Wastewater from Fertilizer Production in a Three‐Phase Flow Airlift Loop Bioreactor

Study of Nitrogen Removal Efficiency of the Filled Bed Reactors Using Alkali-Treated Corncobs-Sulfur (mixotrophic) for Treating the Effluent from Simulated Urban Wastewater Plants

Study on Treatment of Micropolluted Source Water by Immobilized Nitrobacteria

Treatment of Chemical Industrial Wastewater for High Ammonia-Nitrogen with Embedded Immobilized Microorganisms Technological Processes

Treatment of Fine Chemistry Wastewater Using Gel-embedded Nitrobacteria

APPLICATION STUDY ON AERATED FLUIDIZED BED WITH IMMOBILIZED MICROORGANISM PELLETS FOR WATER SUPPLY PLANT

Nitrogen removal performance and bacterial flora analysis of a partial nitrification-anaerobic ammonium oxidation-denitrification system treating rare earth element tailings wastewater

Nitrogen Removal and Simultaneous Nitrification and Denitrification in a Fluidized Bed Step-Feed Process

Sustainable Nitrification in Fluidised Bed Reactor with Immobilised Sludge Pellets

Entrapped mixed microbial cell process for combined secondary and tertiary wastewater treatment.

Nitrifying treatment of wastewater from fertilizer production in a multiple airlift loop bioreactor

NITROGEN REMOVAL FROM RURAL SEWAGE BY SUBSURFACE HORIZONTAL-FLOW IN ARTIFICIAL WETLANDS