The Chemical Society of Japan Decomposition of N-Nitrosamines over Zeolites
B. Shen,L. Ma,J. Zhu,Qin-hua Xu
2000-01-01
Abstract:Protecting the environment where human live is one of the challenges faced chemists in 21st century, since the pollution brought by the mordent industry became more and more serious. Among environmental pollutants N-nitrosamines are considered to be important contributors to the total burden of carcinogens, and tobacco, especially the tobacco smoke, along with industrial workplace are believed to be the largest known exposure to N-nitrosamines.1 While much work concentrating minimization of high human exposure to N-nitrosamines had been successfully done in beer, baby nipples and pacifiers, and occupational exposure in the rubber industry,2 less progress was obtained in tobacco and tobacco smoke. Recently zeolite was tried to be enclosed in the cigarette filter and rod to decrease the emission of toxic chemicals including N-nitrosamines during a cigarette burning,3 but the result was not clear. While the content of N-nitrosoanabasine and N-nitrosoanatabine as well as Nnitrosonornicotine seemed to be decreased in the smoke, Nnitrosodimethylamine increased indeed. Moreover, although zeolites had been widely used as selective adsorbents, it is unknown whether zeolite can selectively adsorb N-nitrosamines or not and how strong the adsorption of N-nitrosamine will be on zeolite, which hinders the application of zeolite in controlling pollution of N-nitrosamine in environment. In this letter we report the adsorption of N-nitrosamines on zeolites at high temperature, and characterize the strong adsorption by use of TGDTA and temperature-programmed surface reaction (TPSR). N-Nitrosodimethylamine (NDMA) and N-nitrosopyrrolidine (NPYR) were purchased from Sigma, and the Nnitrosamines standard solutions were prepared by dissolving 5 mL N-nitrosamines in 100 mL methylene chloride. Zeolite NaY and NaZSM-5 used in the studies were commercially available powder, and HZSM-5 obtained by an ion exchange method from the parent zeolite as described previously.4 SiMCM-41 mesoporous molecular sieve was synthesized in our laboratory. 5 The purity of carrier gases N2 and H2 were 99.99%, and that of He was 99.999%. Adsorption of N-nitrosamines was performed in a fixedbed microreactor filled with 5 mg zeolite catalysts, and the sample was directly heated to the given temperature without activation. The flow rate of H2 or He carrier gases was 30 mL/min, and the N-nitrosamine standard solution was pulse injected on the sample with an amounts of 2 μL each time. Gaseous effluent was analyzed by an on-line Varian 3700 gas chromatograph, and the decrement in the ratio of NPYR or NDMA to the solvent was utilized to calculate the amount of Nnitrosamine adsorbed on zeolite. Temperature programmed surface reaction (TPSR) of adsorbed N-nitrosamine was carried out in a flow reactor. A zeolite sample of 40 mg, in 20-40 meshes, was activated at 773 K in N2 for 2 h, then cooled to 313 K prior to pulse injection of N-nitrosamine solution at 25 mL/g. After the sample was purged with N2 at 313 K for 20 minutes, the temperature rose to 773 K at a rate of 10 K/min. The NOx liberated in the TPSR process was converted to NO2 by passing through a CrO3 tube, and then absorbed in a solution of sulfanilamide and N-(1-naphthyl)ethylenediamine dihydrochloride. The amount of NO2 was detected by colorimetric method6 and represented the amount of N-nitrosamine decomposed. TG-DTA was performed on a STD-2960 thermogravimetric-differential thermal analyzer. Zeolites sample, adsorbed N-nitrosamine in the same procedure as that for TPSR, was heated in N2 to 1073 K at a rate of 20 K/min. NPYR is of five-membered ring compounds while NDMA is of chained compounds. Both of them are strong carcinogenic compounds existing widely in foods and beverages such as beer and bacon along with tobacco and tobacco smokes. As Figure 1 reveals, NPYR or NDMA in methylene chloride solution