Abstract:Nucleation probabilities for binary heterogeneous nucleation have been measured quantitatively. Heterogeneous nucleation of binary n-propanol-water vapor mixtures on partially soluble 6.9-nm NaCl particles and on nonsoluble oxidized and nonoxidized 8-nm Ag particles at a constant nucleation temperature of 288 K (NaCl) or 285 K (Ag) has been investigated experimentally and theoretically. An expansion chamber was applied to generate supersaturated vapor mixtures. Number concentrations of particles activated to condensational growth were determined optically for various vapor phase activities at constant temperature. Nucleation probabilities have been measured as functions of the vapor phase activities for several n-propanol-water vapor mixing ratios. Beyond certain vapor phase activities a sharp onset of heterogeneous nucleation was observed both for NaCl and for Ag particles. For insoluble particle surfaces the theoretical slopes of the nucleation probability versus vapor phase activity curves were found to be somewhat steeper as compared to the experiment. On the other hand, for soluble particles the experimental slopes were found to be in satisfactory agreement with theory. The onset of the nucleation process is defined at an activity value where 50% of the particles were activated to condensational growth. Onset activities were obtained for various mixing ratios of the binary vapor mixtures. In the case of NaCl nuclei for n-propanol rich mixtures, the heterogeneous nucleation calculations based on a thermodynamically consistent version of Fletcher theory and an experimentally determined contact angle provide a reasonable approximation of the experimental data. However, it appears that the Fletcher theory is not applicable in the region of transition from n-propanol rich to water rich mixtures. Based on the Köhler theory of activation of soluble particles, a theory was formulated accounting for the presence of two condensable vapors and limited solubility of NaCl in water-propanol liquid mixtures. This approach provides a satisfactory description of the transition from activation of soluble particles to nucleation of vapors on insoluble particles. In the case of silver particles Fletcher theory with macroscopic experimental contact angles as well as with contact angle zero results in strong deviations from experimental data. A significant improvement was achieved by introducing fit contact angles, which are substantially lower than the macroscopic experimental values and may be considered as approximate values of the microscopic contact angles.

Heterogeneous Nucleation on Particle Seeds With Different Wettabilities

Homogeneous and Heterogeneous Nucleation of Potash Alum in Drop-Based Microfluidic Device

Heterogeneous Nucleation of Vapor on Insoluble Particles Predicted by an Improved Classical Nucleation Theory

Effects of seed particle size and composition on heterogeneous nucleation of n-nonane

The Influence of Particle Solubility on Heterogeneous Nucleation in Binary Vapor Mixtures

Heterogeneous Multicomponent Nucleation Theorems For The Analysis Of Nanoclusters

The Molecular Approach To Heterogeneous Nucleation

Heterogeneous Nucleation in Non-Uniform Media: Numerical Simulations

A molecular dynamics study on the boundary between homogeneous and heterogeneous nucleation

The Effect of Seed Particle Charge on Heterogeneous Nucleation

Heterogeneous Nucleation on Concave Rough Surfaces: Thermodynamic Analysis and Implications for Nucleation Design

Thermodynamics of heterogeneous crystal nucleation in contact and immersion modes

Igniting homogeneous nucleation

Molecular dynamics study of water molecules nucleation for fine particle removal: Effects of wettability and aggregation modes and comparison with experiment

Nucleation Probability in Binary Heterogeneous Nucleation of Water-N-propanol Vapor Mixtures on Insoluble and Soluble Nanoparticles.

Heterogeneous Nucleation Theorems for Multicomponent Systems

Heterogeneous critical nucleation on a completely-wettable substrate

Effect of Nucleation Heterogeneity on Mineral Precipitation in Confined Environments

Molecular Dynamics Simulation of Homogeneous Nucleation and Growth of Supercooled Al Liquid

Numerical Investigation of Effects of Particle Properties on Nucleation Process in a Sulfuric Acid–water Vapor Mixture: Homogeneous Versus Heterogeneous

Dynamics of homogeneous nucleation