Abstract:Electrochemical double layer capacitors (EDLCs), are energy storage devices featuring many advantages, including long cycle life, low internal resistance, and high power densities (i.e. fast charge/discharge rates). Due to these advantages EDLCs have drawn much attention recently, and have been applied to electric/hybrid vehicles, heavy-construction equipment, electronics, and grid utility storage. The most common electrode material for EDLCs is porous activated carbon with the advantages of low cost, abundant resources, and simple processing. In this present work, carbon materials for EDLCs were hydrothermally synthesized from low-cost bio-polymer precursors. Hydrothermal synthesis (HTS) uses simple equipment and runs under mild conditions; the process also uses environmentally friendly precursors and does not produce any hazardous waste. HTS provides a facile method for the development of inexpensive, high- performance carbon materials. In this work, low cost precursors were obtained locally. The precursors were ground and mixed with DI water, and the solution was then sealed in a Teflon lined pressure vessel. The pressure vessel was heated to 200 °C for 24 hours. After the reactor cooled down, the as-synthesized carbons were harvested by filtration and dried in an oven at 120 °C overnight. The morphology of the as-synthesized carbons was characterized by scanning electron microscopy (SEM) as shown in Figure 1. The as-synthesized carbons went through a one-step activation, which increased the surface area to over 1000 m2/g, with 70% micro porosity. Electrodes were made, and tested in 1.8M TEMABF4in PC and 38% sulfuric acid. Cyclic voltammetry (CV) and galvanostatic charge-discharge tests were run on these activated carbons to study the electrochemical performance. The activated carbons showed very nice capacitor characteristics such as rectangular CV curves and very fast charge-discharge rates in both organic and aqueous electrolytes, as shown in Fig 2. The specific capacitance of these materials in organic electrolyte was ~90-120 F/g and had a volumetric capacitance of ~40-60 F/cc, while in aqueous electrolyte the gravimetric capacitance ranged from 180-200 F/g and 100-120 F/cc.

Highly Mesoporous and High Surface Area Carbon: A High Capacitance Electrode Material for EDLCs with Various Electrolytes

Mesoporous activated carbon fiber as electrode material for high-performance electrochemical double layer capacitors with ionic liquid electrolyte

High performance electrode materials for electric double-layer capacitors based on biomass-derived activated carbons

Preparation and Electrochemical Properties of Fluorinated Mesoporous Carbon Foams for Electric Double-Layer Capacitors

Ultramicroporous Carbon Nanoparticles for the High-Performance Electrical Double-Layer Capacitor Electrode

Carbon Electrodes with Ionophobic Characteristics in Organic Electrolyte for High-Performance Electric Double-Layer Capacitors

Bio-Polymer Derived Activated Carbons for Electrochemical Double Layer Capacitors

Synthesis of a Very High Specific Surface Area Active Carbon and Its Electrical Double-Layer Capacitor Properties in Organic Electrolytes

Activated carbon prepared from PVDC by NaOH activation as electrode materials for high performance EDLCs with non-aqueous electrolyte

High-capacitance carbon electrode prepared by PVDC carbonization for aqueous EDLCs

Exfoliated Mesoporous 2D Covalent Organic Frameworks for High‐Rate Electrochemical Double‐Layer Capacitors

Mesoporous Carbon Materials As Electrodes for Electrochemical Double-Layer Capacitor

A novel electrode material for electric double-layer capacitors

Preparation of kraft lignin-based activated carbon fiber electrodes for electric double layer capacitors using an ionic liquid electrolyte

Nanostructured activated carbons from natural precursors for electrical double layer capacitors

Honeycomb-like Hierarchical Porous Activated Carbons from Biomass Waste with Ultrahigh Specific Surface Area for High-Rate Electrochemical Capacitors

ELECTRIC DOUBLE LAYER CAPACITORS WITH CARBON NANOTUBES ELECTRODES AND GEL POLYMER/POLYACID ELECTROLYTES

IntegratingCarbon Dots with Porous Hydrogels to ProduceFull Carbon Electrodes for Electric Double-Layer Capacitors

Electrochemical Characterization of Mesopore Activated Carbon Electrodes for Electric Double-Layer Capacitors

Activated High Specific Surface Area Carbon Aerogels for Edlcs

Quaternary Ammonium Functionalized Poly(arylene Ether Sulfone)/poly(vinylpyrrolidone) Composite Membranes for Electrical Double-Layer Capacitors with Activated Carbon Electrodes