Abstract:Since 1998, the Au–O–Ti4+ sites of Au/Ti-based catalysts have been widely accepted as the active sites for propene epoxidation with H2 and O2 at a relatively high temperature, although they are limited by poor H2 efficiency. Herein, we demonstrate a novel Au–O–Ti3+ active site aiming at low-temperature propene epoxidation. Notably, this active site results in a sharp shift in the optimum temperature, from 200 to 138 °C, and allows the catalyst to maintain an unprecedented H2 efficiency of 43.6%, a high propylene oxide (PO) selectivity of 90.7%, and a stability of over 100 h. The Au–O–coordinatively unsaturated Ti3+ active site is quantitively constructed by tuning the amount of Si–OH and Bu3NH+ in post-treated silicalite-1 seeds. Through operando ultraviolet–visible (UV–vis) spectroscopy, the dynamic evolution of the Ti–OOH intermediate was investigated. It was found that the Ti–OOH generation rate is higher on Au–O–Ti3+ than on conventional Au–O–Ti4+ sites. Moreover, ammonia temperature-programmed desorption (NH3-TPD) and X-ray photoelectron spectroscopy (XPS) characterizations, together with density-functional theory (DFT) calculations, demonstrated that the coordinatively unsaturated Ti3+ sites promote electron transfer between Au and Ti3+, thereby enhancing the O2 adsorption ability of the catalyst and promoting the in situ formation of H2O2 and the Ti–OOH intermediate, even at a low temperature. The insights and methodology reported here not only shed new light on maximizing H2 efficiency over a coordinatively unsaturated Ti3+ structure of titanium silicate-1 but also open up new opportunities for industrial direct gas-phase propene epoxidation in a low temperature range.

Efficient and Selective Epoxidation of Styrene with TBHP Catalyzed by Au(25) Clusters on Hydroxyapatite.

Epoxidation of styrene via anhydrous t-butylhydroperoxide catalyzed by supported Au/Fe(OH)3

Catalytic Enantioselective Epoxidation of Tertiary Allylic and Homoallylic Alcohols.

Highly Selective Oxidation of Styrene to Benzaldehyde over Fe 3 O 4 Using H 2 O 2 Aqueous Solution As Oxidant

Iron and Molybdenum Modified Phosphotungstates Towards Selective Oxidation of Styrene to Benzaldehyde

Catalytic Oxidation of Styrene and Its Reaction Mechanism Consideration over Bimetal Modified Phosphotungstates

Catalytic epoxidation of styrene over copper hydroxyphosphate Cu2(OH)PO4

Epoxidation of Propylene with Dilute H 2 O 2 over Titanium Silicalite Containing Trace Aluminum

High-Performance Styrene Epoxidation with Vacancy-Defect Cobalt Single-Atom Catalysts

Combining trace Pt with surface silylation to boost Au/uncalcined TS ‐1 catalyzed propylene epoxidation with H 2 and O 2

Mesoporogen-Free Strategy to Construct Hierarchical TS-1 in a Highly Concentrated System for Gas-Phase Propene Epoxidation with H 2 and O 2

Mesoporous Metal-Organic Frameworks NH2-MIL-101(Cr) as an Efficient Photocatalyst for the Epoxidation of Styrene

Direct Propylene Epoxidation with H-2 and O-2 over in Modified Au/Ts-1 Catalysts

Efficient photocatalytic epoxidation of styrene over a quantum-sized SnO2 on carbon nitride as a heterostructured catalyst

Engineering a Coordinatively Unsaturated Au–O–Ti3+ Structure Toward Unprecedented H2 Efficiency for Low-Temperature Propene Epoxidation with H2 and O2

A novel Ag-loaded 4 Å zeolite as an efficient catalyst for epoxidation of styrene

Kinetic Studies and Reaction Network in the Epoxidation of Styrene Catalyzed by the Temperature-Controlled Phase-Transfer Catalyst [(C18H37)2(CH3)2N ]7[PW11O39]

Efficient photocatalytic epoxidation of styrene over a quantum-sized SnO<sub>2 </sub>on carbon nitride as a heterostructured catalyst

Zeolite crystal size effects of Au/uncalcined TS-1 bifunctional catalysts on direct propylene epoxidation with H2 and O2

Efficient Organocatalytic Synthesis of Styrene Oxide from Styrene and Its Kinetic Study in a Continuous-Flow Microreaction System

Study of Higher Selectivity to Styrene Oxide in the Epoxidation of Styrene with Hydrogen Peroxide over La-Doped MCM-48 Catalyst