Abstract:Effect of varying surface structures of the inner rotating cylinder on characteristics of droplet formed in a liquid-liquid Taylor-Couette (TC) reactor is investigated. Two novel surface structures of inner cylinders, designed with axially corrugated surface (N40) and with typical three-dimensional roughness (NZ40), respectively, were adopted for the investigation. The high-speed camera visualization was used to measure the droplet size while CFD modelling was applied to predict the fluid dynamics of TC flows with such two inner cylinders and a smooth surface inner cylinder, thus revealing the effect of inner cylinder configuration on the droplet formation in the TC flows. The experimental results have clearly indicated that both the rotation speed and surface configuration variation of the inner cylinders affect the generated droplet size and distribution. As the rotation speed increases, the droplet size is obviously reduced for all types of inner cylinder configurations. Compared with the conventional smooth surface inner cylinder, the two new types of inner cylinders with special surface structures can produce much smaller droplets, especially for the case of N40 surface structure inner cylinder, with which the smallest droplet size was found at all the experimental conditions. CFD modelling results have demonstrated that the surface configurations of inner cylinder can significantly affect the turbulence generation, consequently altering the distributions of turbulent kinetic energy and local turbulence shear strain rate. As a result, the droplet size was found to be controlled by the change of the local turbulent dissipation rate that was strongly associated with the surface structures of inner cylinders. Empirical correlations that correlate the droplet size with the Weber number and Reynolds number were proposed based on the high-speed camera visualization data.(c) 2022 The Authors. Published by Elsevier Ltd. This is an open access article under the CC BY license (http:// creativecommons.org/licenses/by/4.0/).

Statistical Characteristics of Taylor Bubbles in Cryogenic Gas Liquid Slug Flow—I. Taylor Bubble Length

Visualisation Research on Characteristics of the Cryogenic Slug Flow in Vertical and Inclined Tubes

Cryogenic Liquid Slug and Taylor Bubble Length Distributions in an Inclined Tube

EXPERIMENTAL STUDY ON THE CRYOGENIC TAYLOR BUBBLE AND LIQUID SLUG LENGTHS IN AN INCLINED PIPE

Online Parameters Measurement of Taylor Flow in Small Channels Using Optical Technique

Experimental study on initial position of Taylor bubbles of cryogenic two-phase slug flow in inclined pipes

Experimental Study on the Initial Position Distribution of Taylor Bubbles in Cryogenic Upward Inclined Tubes

Study on bubble size distribution and local gas holdup in bubble column

Experimental Study of Motion of Nitrogen Taylor Bubbles and Liquid Slugs in Inclined Tubes

Experimental study on the length of the slug unit in cryogenic upward inclined tube

Experimental Study on Boiling Flow of Liquid Nitrogen in Vertical Tubes: Taylor Bubble Length Distribution and Rising Velocity

Study on the Flow Structure and Its Effects on the Interaction and Formation of Cryogenic Taylor Bubbles by Piv Technique and Pod Analysis

Influence of Short-Draft Tube on Fluid Dynamics in Bubble Column with CFD

Experimental study on the cryogenic two-phase slug flow characteristic in inclined pipes-Taylor bubble rising velocity

Experimental study of Taylor bubble flow in non-Newtonian liquid in a rectangular microchannel

Effect of Inner Cylinder Configuration on Liquid Droplet Dispersion and Size Distributions in a Taylor-Couette Reactor

Effects of gas inlet angle and cross-section aspect ratio on Taylor bubble behavior in microchannels

Thermal and Flow Characteristics of Water-Nitrogen Taylor Flow Inside Vertical Circular Tubes

Bubble and frictional characteristics of gas-liquid Taylor flow in capillary tube

Scaling of the Bubble/slug Length of Taylor Flow in a Meandering Microchannel

Experimental Study on the Liquid Slug of Cryogenic Slug Flow in Inclined Tubes