Abstract:The effect of homogenization alone or in combination with high-temperature, short-time (HTST) pasteurization or UHT processing on the whey fraction of milk was investigated using highly sensitive spectroscopic techniques. In pilot plant trials, 1-L quantities of whole milk were homogenized in a 2-stage homogenizer at 35°C (6.9 MPa/10.3 MPa) and, along with skim milk, were subjected to HTST pasteurization (72°C for 15 s) or UHT processing (135°C for 2 s). Other whole milk samples were processed using homogenization followed by either HTST pasteurization or UHT processing. The processed skim and whole milk samples were centrifuged further to remove fat and then acidified to pH 4.6 to isolate the corresponding whey fractions, and centrifuged again. The whey fractions were then purified using dialysis and investigated using the circular dichroism, Fourier transform infrared, and Trp intrinsic fluorescence spectroscopic techniques. Results demonstrated that homogenization combined with UHT processing of milk caused not only changes in protein composition but also significant secondary structural loss, particularly in the amounts of apparent antiparallel β-sheet and α-helix, as well as diminished tertiary structural contact. In both cases of homogenization alone and followed by HTST treatments, neither caused appreciable chemical changes, nor remarkable secondary structural reduction. But disruption was evident in the tertiary structural environment of the whey proteins due to homogenization of whole milk as shown by both the near-UV circular dichroism and Trp intrinsic fluorescence. In-depth structural stability analyses revealed that even though processing of milk imposed little impairment on the secondary structural stability, the tertiary structural stability of whey protein was altered significantly. The following order was derived based on these studies: raw whole>HTST, homogenized, homogenized and pasteurized>skimmed and pasteurized, and skimmed UHT>homogenized UHT. The methodology demonstrated in this study can be used to gain insight into the behavior of milk proteins when processed and provides a new empirical and comparative approach for analyzing and assessing the effect of processing schemes on the nutrition and quality of milk and dairy product without the need for extended separation and purification, which can be both time-consuming and disruptive to protein structures.

Study on the Stability of Milk Whey Protein Solution with Different Acidity

Influence of Temperature,ph and Salts on the Stability of Emulsions Stabilized by Whey Protein

Systematical Characterization of Physiochemical and Rheological Properties of Thermal-Induced Polymerized Whey Protein.

On the Stability of Casein System in Acidic Condition

Research on the Characteristic of Caseins at Different pH

Effects of Different Ph Conditions on Interfacial Composition and Protein-Lipid Co-Oxidation of Whey Protein Isolate-Stabilised O/W Emulsions

Change in the structural and functional properties of goat milk protein due to pH and heat.

Stability of Acidic Goat Milk Beverage

Research Development on the Stabilization of Casein Micelles Induced by Pectin in the Acidified Milk Drinks

Thermal stability of whey protein concentrates

pH-induced physiochemical and structural changes of milk proteins mixtures and its effect on foaming behavior

The Separation and Characteristic of Caseins in Milk

Effect of Ph on Heat Stability of Yak Milk Protein

Seven sour substances enhancing characteristics and stability of whey protein isolate emulsion and its heat-induced emulsion gel under the non-acid condition

Influence of the Stability and Its Structure Characteristics of Buffalo Yogurt with Mango Puree Induced by Several Critical Technological Conditions

Stability of Casein and High-Ester Pectin in Acid Conditions

Kinetics of heat-induced microgels of whey proteins and casein micelles

Study on the Stability of Acidic Juice-Milk

Effect of homogenization and pasteurization on the structure and stability of whey protein in milk.

The effect of storage temperature and storage time on the stability of reconstituted milk

The Influence of pH on the Emulsification Properties of Heated Whey Protein-Pectin Complexes