Abstract:With regard to the structural characteristics of the McPherson suspension system, when a vehicle is being driven on a rough road surface, the force direction of the suspension varies. This poses challenges to the vehicle’s driving safety and handling stability. Based on Lagrangian equations, this paper proposes a new nonlinear semi-vehicle suspension model and presents comparative studies, conducted through simulation, on the estimated accuracy and computational overhead of the small-computational-overhead extended Kalman filter (EKF) and unscented Kalman estimation (UKF) methods, and on the effectiveness of the skyhook sliding mode control (SHSMC) and nonlinear skyhook-sliding mode control (NSHSMC) semi-active suspension control methods. The response of the vehicle to the state estimation algorithm was evaluated through computer simulations using the Carsim vehicle dynamic software. The simulation results reveal that the vehicle dynamic states were satisfactorily estimated when the vehicle was driven on a rough road surface. Compared with the small-computational-overhead EKF algorithm, the estimated results of these variables based on the UKF algorithm have higher accuracy. However, the UKF algorithm requires longer computation time compared with the EKF algorithm. The SHSMC control algorithm achieved greater improvement for the vehicle’s drive handling stability in the 6–10-Hz vibration region compared with the NSHSMC control algorithm. In a high-frequency region over 10Hz, the semi-active suspension controlled by the SHSMC method had a more adverse effect on the driving comfort.

The Study of A Simulation Test Method for A Semi-active Vehicle Suspension

Control and Simulation of Semi-Active Suspension Based on MRF Damper

Research on Co-simulation and Test of Semi-active Suspension

Comparative Simulation Study on Two Estimation Methods and Two Control Strategies for Semi-Active Suspension

On Fuzzy Control Strategy of Nonlinear Semi-Active Suspension System

A Study On A Intelligent Controller For Vibration Control Of Semi-Active Suspension System

Fuzzy Control and Simulation of Semi-Active Suspension on a Vehicle

Simulation and Study on the Control of Vehicle Semi-Active Suspension System

Study and Simulation of Vehicle Suspension System

A Test Research on Semi-active Suspension System

Analysis on new semi-active control strategies to reduce lateral vibrations of high-speed trains by simulation and hardware-in-the-loop testing

A new semi-active control strategy on lateral suspension systems of high-speed trains and its application in HIL test rig

Study on the Ride Performance of a Semi-Active Air Suspension Vehicle under Complex Models Based on Co-Simulation

Hierarchical Preview Control and Simulation of Semi-active Motorcycle Suspension

The Development of a Vehicle Semi-Active Suspension with Magnetorheological Damper

Coordinate Control of Vehicle Semi-Active Suspension Based on Adams/Car and Matlab/Simulink

Active Suspension Control of Quarter-Car System With Experimental Validation

Sliding Mode Control of Semi-active Suspension Based on Reference Model

Simulation study on vibration reduction characteristics of two-degree of freedom suspension system in a quarter vehicle

Vehicle Suspension Design with Semi-Active Inerter and Semi-Active Damper Configuration

Study on the coordination control of active suspension employing linear motor based on co-simulation