Abstract:The propulsion system is one of the important and vulnerable sub-systems in a strap-on launch vehicle. Among different failure modes, the thrust drop fault is the most common and remediable one. It degrades vehicle attitude tracking ability directly. To this end, this paper focuses on the design and application of attitude reconstruction problems with a thrust loss fault during the ascending flight phase. We firstly analyze the special failure modes and impacts on the propulsion system through a Failure Modes and Effects Analysis (FMEA). Then, six degrees of freedom dynamic and kinematic models are formulated, which are integrated into the Matlab/Simulink environment afterward. The above models' validation is realized through numerical simulations with different fault severity. Simulation results show that the max attitude deviation is only 0.67° approximately in the pitch angle channel under normal conditions, and the flight attitude angle deviation is directly proportional to the thrust loss percentage when the thrust drop fault occurs. Based on the validated models, a practical reconfigurable ideal through adjusting the control allocation matrix is analyzed. Then, an automation redistribution mechanism based on the moment equivalent principle before and after the thrust drop is proposed to realize proportional allocation of virtual control command among the actuators. The effectiveness of the designed attitude reconstruction method is demonstrated through numerical simulations and comparison analysis under various fault scenarios. The results show that the rocket attitude can be quickly adjusted to the predetermined program angle within about 2.5 s after the shutdown failure of a single engine, and the flight speed and altitude can also reach the required value with another 17 s engine operation. Therefore, the designed control reconfiguration strategy can deal with the thrust loss fault with high practicability and can be applied to real-time FTC systems. Last but not least, conclusions and prospects are presented to inspire researchers with further exploration in this field.

The Application of Reconfigurable Control for Stuck Fault of Left Elevator of Missile with Thrust Vector Control

Adaptive Control for Quadrotors with Uncertain and Faulty Actuators

Robust Adaptive Fault-Tolerant Coordinated Control For Biaxial Gantry System With Friction Compensation

Control reconfiguration design for control surface fault of small unmanned aerial vehicle

Fault Diagnosis and Reconfigurable Control for Underwater Vehicles

Adaptive Backstepping Sliding Mode Fault Tolerant Control for Satellite Attitude under Actuator Faults

Actuator fault identification and reconfigurable control for aircraft

Fault-tolerant control for reentry hypersonic vehicle with blended aerodynamic surfaces and RCS

Adaptive fault identification and reconfigurable fault‐tolerant control for unmanned surface vehicle with actuator magnitude and rate faults

Fault-Tolerant Attitude Control Incorporating Reconfiguration Control Allocation for Supersonic Tailless Aircraft

Autonomous Attitude Reconstruction Analysis for Propulsion System with Typical Thrust Drop Fault

Fault Diagnosis and Reconfigurable Control for Flight Control Systems with Actuator Failures

Adaptive Fault-Tolerant Control of a Hybrid VTOL UAV against Actuator Faults and Model Uncertainties under Fixed-Wing Mode

Multiple model fault diagnosis and fault tolerant control for the launch vehicle's attitude control system

Improved fault detection and control allocation for hypersonic re‐entry vehicle subject to intermittent fault and disturbance

Reinforcement learning-adaptive fault-tolerant IGC method for a class of aircraft with non-affine characteristics and multiple uncertainties

Lateral thrust and aerodynamics blended control system design based on auto disturbance-rejection controller

Reentry Attitude Fault Tolerant Control for RLV Based on Adaptive Second-Order Nonsingular Fast Terminal Sliding Mode

Prescribed-performance Fault-Tolerant Control for Feedback Linearisable Systems with an Aircraft Application

Reconfiguration control allocation of actuator faults for tailless aircraft with low aspect ratio

Partial integrated guidance and control design for supersonic missile based on disturbance rejection