Abstract:A series of experiments were performed to investigate the relationship between syngas composition (H2/CO/CO2/N2/O2) and NO formation. Laser-saturated fluorescence measurements of NO in a premixed syngas flat flame from a heat flux burner were recorded for various fuel compositions, dilution ratios and equivalence ratios. Quantitative measurements were compared with the predictions from CHEMKIN software using four different chemical mechanisms, i.e., GRI mech 3.0, Chemical Reaction Engineering and Chemical Kinetics 1407, GDF-Kin 3.0, and the Mendiara and Glarborg mechanism; each mechanism included reaction subsets for NOx formation. These models were validated against a CH4 flame; the GDF-Kin 3.0 mechanism produced the best agreement with measurements. NO measurements for CO/H2 syngas fuel with 50% CO2 dilution at various equivalence ratios found the maximum NO production near stoichiometry. The majority of NO produced for these conditions is predicted to come from the combination of the NNH and N2O pathways. Investigation of NO production during combustion of different CO/H2 ratio syngas diluted with 60% N2 showed that increasing the H2 fraction decreased the total NO concentration. However, normalizing the NO production rate by the fuel mass consumption rate showed H2 produces more NO per gram of fuel consumed. Predictions of temperature and NO rate of production along the flame axis showed that the syngas with high H2 content had a flame front closer to the burner exit and NO production rate greater than the high CO case. Dilution of CO/H2 syngas fuel with N2 and CO2 showed that CO2 has a stronger reduction in NO emission than N2. GDF-Kin 3.0 predicted that dilution with CO2 caused a greater reduction in flame temperature than the same volume of N2. Predicted NO rate of production and reaction sensitivity analysis predicted that the Zel’dovich pathway was dominant for undiluted syngas. However, as the flame temperature reduced, the Zel’dovich pathway was inhibited to a greater extent than the N2O and NNH pathways so that, at high dilution, NO production was driven by the N2O and NNH pathways.

Effects of CO2 Dilution on NOx Formation Characteristics in Syngas Diffusion Flames

Effects of Different Air Diluents on Nox Formation in Counterflow Syngas Diffusion Flames

Investigation of NO formation in premixed adiabatic laminar flames of H 2 /CO syngas and air by saturated laser-induced fluorescence and kinetic modeling

Effect of dilution of fuel in CO 2 on the conversion of NH 3 to NO x during oxy-fuel combustion

Effects of CO 2 and N 2 Dilution on the Combustion Characteristics of H 2 /CO Mixture in a Turbulent, Partially Premixed Burner

NO and CO Emission Characteristics of Laminar and Turbulent Counterflow Premixed Hydrogen-Rich Syngas/Air Flames

Effects of CO2 Dilution and CH4 Addition on Laminar Burning Velocities of Syngas at Elevated Pressures: an Experimental and Modeling Study

Effect of CO2 and N2 Dilution on Laminar Premixed MTHF/air Flames: Experiments and Kinetic Studies

Laminar Flame Speeds of H2/CO with CO2 Dilution at Normal and Elevated Pressures and Temperatures

Effects of CO 2 Dilution and CH 4 Addition on Laminar Burning Velocities of Syngas at Elevated Pressures: An Experimental and Modeling Study

Evaluation of the Chemical Effect of Carbon Dioxide Dilution to Fuel on Soot Formation in Co-Flow Laminar Ethylene and Propane Diffusion Flames

Effects of Ch4 Content on No Formation in One-Dimensional Adiabatic Flames Investigated by Saturated Laser-Induced Fluorescence and Chemkin Modeling

Effects of H2/CO ratio and CO2 dilution on the explosion behavior and flame evolution of syngas/air mixtures

Experimental and numerical research on the effects of pressure and CO2 dilution on soot formation in laminar co-flow methane/air diffusion flames

Detailed investigation of NO mechanism in non-premixed oxy-fuel jet flames with CH 4 /H 2 fuel blends

Comprehensive kinetic study on ammonia/ethylene counter-flow diffusion flames: influences of diluents

Numerical Simulations of the Influence of Inert Gases (N 2 /CO 2 ) on Combustion Characteristics of Laminar-Premixed Biosyngas Flame

Effect of diluent gas on propagation and explosion characteristics of hydrogen-rich syngas laminar premixed flame

Nitric Oxide of MILD Combustion of a Methane Jet Flame in Hot Oxidizer Coflow: Its Formations and Emissions under H2O, CO2 and N-2 Dilutions

Ozone Effect on the Flammability Limit and Near-Limit Combustion of Syngas/air Flames with N 2 , CO 2 , and H 2 O Dilutions

Numerical analysis of NOx formation mechanisms and emission characteristics with different types of reactants dilution during MILD combustion of methane and coke oven gas