Abstract:It has been predicted that several changes will occur when premixed flames are subjected to the extreme levels of turbulence that can be found in practical combustors. This paper is a review of recent experimental and DNS results that have been obtained for the range of extreme turbulence, and it includes a discussion of cases that agree or disagree with predictions. "Extreme turbulence" is defined to correspond to a turbulent Reynolds number (Re-T, based on integral scale) that exceeds 2800 or a turbulent Karlovitz number that exceeds 100, for reasons that are discussed in Section 2.1. Several data bases are described that include measurements made at Lund University, the University of Sydney, the University of Michigan and the U.S. Air Force Research Lab. The data bases also include DNS results from Sandia National Laboratory, the University of New South Wales, Newcastle University, the California Institute of Technology and the University of Cambridge. Several major observations are: (a) DNS now can be achieved for a realistic geometry (of the Lund University jet burner) even for extreme turbulence levels, (b) state relations (conditional mean profiles) from DNS and experiments do tend to agree with laminar profiles, at least for methane-air and hydrogen-air reactants that are not preheated, and (c) regime boundaries have been measured and they do not agree with predicted boundaries. These findings indicate that the range of conditions for which flamelet models should be valid is larger than what was previously believed. Additional parameters have been shown to be important; for example, broken reactions occur if the "back-support" is insufficient due to the entrainment of cold gas into the product gas. Turbulent burning velocity measurements have been extended from the previous normalized turbulence levels (u'/S-L) of 24 up to a value of 163. Turbulent burning velocities no longer follow the trend predicted by Shchelkin but they tend to follow the trend predicted by Damkohler. The boundary where flamelet broadening begins was measured to occur at Re-Taylor = 13.8, which corresponds to an integral scale Reynolds number (Re-T) of 2800. This measured regime boundary can be explained by the idea that flame structure is altered when the turbulent diffusivity at the Taylor scale exceeds a critical value, rather than the idea that changes occur when Kolmogorov eddies just fit inside a flamelet. A roadmap to extend DNS to complex chemistry and to higher Reynolds numbers is discussed. Exascale computers, machine learning, adaptive mesh refinement and embedded DNS show promise. Some advances are reviewed that have extended the use of line and planar PLIF and CARS laser diagnostics to studies that consider complex hydrocarbon fuels and harsh environments. (C) 2019 Elsevier Ltd. All rights reserved.

Local Extinction and Reignition in Non-Premixed Turbulent Jet H2/N2 Diffusion Flames

Extinction in Non-Premixed Ethanol Spray Flames Using Direct Numerical Simulation

A Direct Numerical Simulation Study of Flame Structure and Stabilization of an Experimental High Ka CH4/air Premixed Jet Flame

Premixed Flames Subjected to Extreme Turbulence: Some Questions and Recent Answers

A direct numerical simulation study of turbulence intensity effects on NOx formation in freely propagating premixed flames

Local Flame And Flow Properties Of Propagating Premixed Turbulent Flames During Light-Round Process In A Micca-Type Annular Combustor

Extinction of buoyant turbulent non-premixed flames under reduced oxygen concentrations

Lagrangian Investigation and Chemical Explosive Mode Analysis of Extinction and Re-Ignition in H2/CO/N2 Syngas Non-Premixed Flame

Large eddy simulation of turbulent non-premixed oxy-fuel jet flames with different Reynolds numbers

Numerical Investigation of the Local Extinction and Re-Ignition Mechanisms of Premixed Flame in a Micro Combustor with a Flame Holder and Preheating Channels

Numerical Analysis and Flamelet Modeling of NOx Formation in a Thermodiffusively Unstable Hydrogen Flame

Numerical Study on Oscillatory Propagation Dynamics and Physics Near the Limits of Planar Freely Propagating Premixed Flames

One-dimensional Turbulence Simulation of Jet H_2/N_2 Diffusion Flame

Chemical Explosive Mode Analysis for Local Reignition Scenarios in H2/N2 Turbulent Diffusion Flames

Improved Understanding of Fire Suppression Mechanism with an Idealized Extinguishing Agent

The Effects of Soret Diffusion on Extinction Limit in Premixed and Diffusion Counterflow N-Butane/Air Flames

Near-extinction Transient Behaviors of Counterflow Nonpremixed Flames in a Porous Spherical Burner at Very Low Stretch Rate

Extinction studies of near-limit lean premixed syngas/air flames

Ignition and Extinction Modeling of Hydrothermal Flames

An Experimental and Theoretical Investigation of the Dilution, Pressure and Flow-Field Effects on the Extinction Condition of Methane-Air-nitrogen Diffusion Flames

Numerical Study on the Extinction Dynamics of Partially Premixed Meso-Scale Methane-Air Jet Flames with Hydrogen Addition