Abstract:The aerodynamic performance of a reduced-scale coaxial rigid rotor system in hover and steady forward flights was experimentally investigated to gain insights into the effect of interference between upper and lower rotors and the influences of the advance ratio, shaft tilt angle and lift offset. The rotor system featured by 2 m-diameter, four-bladed upper and lower hingeless rotors and was installed in a coaxial rotor test rig. Experiments were conducted in the Φ3.2 m wind tunnel at China Aerodynamics Research and Development Center (CARDC). The rotor system was tested in hover states at collective pitches ranging from 0° to 13° and it was also tested in forward flights at advance ratios up to 0.6, with specific focus on the shaft tilt angle and lift offset sweeps. To ensure that the coaxial rotor was operating in a similar manner to that of the real flight, the torque difference was trimmed to zero in hover flight, whilst the constant lift coefficient was maintained in forward flight. An isolated single-rotor configuration test was also conducted with the same pitch angle setting in the coaxial rotor. The hover test results demonstrate that the figure of merit (FM) value of the lower rotor is lower than that of the upper rotor, and both are lower than that of the isolated single rotor. Moreover, the coaxial rotor configuration can contribute to better hover efficiency under the same blade loading coefficient (CT/σ). In forward flight, the effective lift-to-drag (L/De) ratio of the coaxial rigid rotor does not monotonously change as the advance ratio increases. Increases in the required power and drag in the case with a high advance ratio of 0.6 leads to the decreasing L/De ratio of the rotor. Meanwhile, the L/De ratio of the rotor is relatively high when the rotor shaft is tilted backward. The increasing lift offset tends to result in reduced required rotor power and an increase in the rotor drag. When the effect of the reduced rotor power is greater than that of the increased rotor drag, the L/De ratio increases as the lift offset increases. The L/De ratio can benefit significantly from lift offset at a high advance ratio, but it is much less influenced by lift offset at a low advance ratio. The forward performance efficiency of the upper rotor is poorer than that of the lower rotor, which is significantly different from the case in the hover flight.

Design of Test Benches for the Hovering Performance of Nano-Rotors

Design and Hover Test of Low Vibration Mach Scale Rotor with Twisted Composite Tailored Blade

Experimental Study to Quantify the Rotor-to-Rotor Interaction Characteristics of a Small Unmanned-Aerial-Vehicle

Control System Design and Flight Testing for a Miniature Unmanned Helicopter

Automated Design Optimization of a Mono Tiltrotor in Hovering and Cruising States

Numerical Simulation and Aerodynamic Investigation of the Intermeshing Rotor in Hover

Wind Tunnel Studies on Hover and Forward Flight Performances of a Coaxial Rigid Rotor

Aerodynamic Simulation of a Typical Multirotor e VTOL Aircraft Configuration.

Rotor Performance Predictions for Urban Air Mobility: Single vs. Coaxial Rigid Rotors

Study On The Mechanism Of The Variable-Speed Rotor Affecting Rotor Aerodynamic Performance

Identification and Reduction of Interactional Noise of a Quadcopter in Hover and Forward Flight Conditions

Design and Analysis of UAV Test Bench for Engine/Motor Characterization

Digital Simulation of Coupled Dynamic Characteristics of Open Rotor and Dynamic Balancing Test Research

Design and Experimental Validation of Permanent Magnet Motor for Propeller Aerodynamic Noise Test

Tri-Rotor Propeller Design Concept, Optimization and Analysis of the Lift Efficiency During Hovering

Improved PVTOL Test Bench for the Study of Over-Actuated Tilt-Rotor Propulsion Systems

High-performance Marangoni hydrogel rotors with asymmetric porosity and drag reduction profile

Aerodynamic analysis of rotor-to-rotor interactions in different octocopter configurations

Design and Flight Performance of a Bio-Inspired Hover-Capable Flapping-Wing Micro Air Vehicle with Tail Wing

Aerodynamic Performance of V8 Octorotor MAV with Different Rotor Configurations in Hover

Experimental Investigation on Hover Performance of a Ducted Coaxial-Rotor UAV