Abstract:Fully developed turbulent pipe flow at Re=11300 as well as Re=5300 is measured by PIV using water as working fluid. Excellent agreement with DNS (Direct Numerical Simulation) by Satake (2000) is achieved by choosing optimum measurement parameters such as spatial resolution, time separation of two images, and number of samples. The test section is 6.7m long stainless steel pipe with transparent PIV measurement section attached seamlessly at the end. The measurement section consists of transparent acrylic circular pipe of 1mm thick and water jacket with square cross section. The water jacket reduces the image distortion due to the pipe curvature in almost entire area of the pipe cross section to negligible level except for the region very close to the pipe wall. For turbulent flow measurement using PIV, the requirement for spatial resolution is very severe in order to resolve the fluctuating velocity field especially at high Reynolds number. Therefore, higher magnification is chosen at the cost of the size of measurement area to assure enough spatial resolution. Consequently, the size of the measurement area is half of the pipe radius and measurement is performed at two regions which are called near-wall region and pipe center. For image analysis, the iterative multi-step cross-correlation algorithm with spatio-temporal gradient method for subpixel refinement is used. Detail of the algorithm can be found in Scarano (1999) and Sugii (2000). The smallest interrogation window is 8x16 pixels which corresponds to 249 x 585μm. The near-wall structure is observed from vector map of fluctuating in-plane velocity components and out-of-plane component of vorticity fluctuation. The shear layer structure is clearly shown by vorticity fluctuation and ejection and sweep motion is also observed. The mean velocity profile and statistics are calculated from 4000 samples of vector map by first taking temporal statistics and then spatial average along streamwise direction and compared with DNS in non-dimensional form using friction velocity. Since accurate measurement of friction velocity is essential for the comparison with DNS, using pressure gradient is not appropriate due to the relatively small pressure drop along the pipe. Therefore, curve-fitting method using near-wall turbulent model developed by McEligot (1984) is applied to calculate friction velocity from the velocity profile in buffer region.

Experimental Study of Turbulent Mixing in A Tee Mixer Using Piv and Plif

Simultaneous Measurements of Velocity and Concentration Fields in an Inclined Jet in Crossflow

Intensification of liquid mixing and local turbulence using a fractal injector with staggered conformation

Experimental Study about Mixing Characteristic and Enhancement of T-jet Reactor

Three-Dimensional Analysis of Flow and Mixing Characteristics of A Novel In-Line Opposing-Jet Mixer

Experimental and Numerical Study on Flow Resistance and Bubble Transport in a Helical Static Mixer

Theoretical And Experimental Aanalysis Of Chaotic Mixing Efficiency Of Plug Flow In Different Geometry

Measurements of turbulence statistics and near-wall structure of fully developed pipe flow at high Reynolds number

Velocity Field and Scalar Field Measurements of Turbulent Buoyant Round Jets in a Two-Layer Stratified Environment

Investigation of three-dimensional flow regime and mixing characteristic in T-jet reactor

Experimental Study on Turbulence Properties in the Dual Nozzle Opposed Impinging Stream Mixer

Development of Piv Technique under Magnetic Fields and Measurement of Turbulent Pipe Flow of Flibe Simulant Fluid

Jet trajectories of liquid mixing in multi-orifice-impinging transverse jet mixer

Experimental Studies of Flow and Mixing of Transverse Jets in Supersonic Crossflows

Experimental and Numerical Study of Mixing Characteristics of A Rectangular Lobed Mixer in Supersonic Flow

Visualization And Piv Measurements Of The Near Wall Structure In A Turbulent Pipe Flow

Investigation of turbulence modification by PIV tracer particles in a supersonic mixing layer

Experimental study on the flow mixing in T-junctions with an impeller

PIV Measurement of Turbulent Bubbly Mixing Layer

Study on the mixing behavior of thin liquid-sheet impinging jets using the PLIF technique

Experimental Study of Structure and Dynamics of Turbulent Stratified Jet