Abstract:For coal semi-char as a by-produced of low-temperature pyrolysis, combustion for power generation is one of the effective utilization methods to realize its clean and efficient utilization. However, the coal semi-char combustion process has a difficult ignition, unstable combustion and low burnout rate. The co-firing of the semi-char with biomass under oxy-fuel conditions can improve the combustion behavior and reduce fossil CO2 emissions. In this paper, the combustion behavior of Shenhua coal semi-char (SHC) co-firing with straw (ST) in O2/CO2 mixture is investigated using thermogravimetric analysis. The results show that each curve lays between those of the individual fuels and presents three peaks (i.e., three stages). The thermogravimetric curves of SHC co-firing with ST can be divided into three stages: the volatile combustion of ST, the co-combustion of SHC and ST fixed-carbons and the SHC fixed-carbon combustion and the decomposition of the difficult pyrolytic material of ST. Blending ST into the SHC can significantly decrease the ignition temperature and improve the comprehensive combustion behavior of blended samples. In increasing the proportion of ST from 25 to 100%, the change of the blended ignition temperature is slight, but the burnout temperature decreases greatly. Kinetic parameters of combustion are calculated by using the Coats–Redfern integral method. Compared to that of stage I and stage III, the activation energy of stage II is significantly lower. As increasing blending ratio from 25% to 100%, the activation energy increases at stage I and decreases at stage III. Furthermore, the O2 concentration obviously affects stage III of 50% SHC + 50% ST, and the thermogravimetric curves at this stage are obviously shifted to the lower temperature zone as the O2 concentration increases. The activation energy of 50% SHC + 50% ST increases as the oxygen concentration increases. Besides, the activation energy shows that the combustion characteristics cannot be determined only by the activation energy obtained by the Coats–Redfern method. These findings can provide useful information for semi-char co-firing with biomass.

Char gasification kinetics using non-isothermal TGA

Experimental Analysis of Intrinsic Kinetics and Rate Profiles for Coal Char Conversion under Different Atmospheres

Study on carbonization of lignin by TG-FTIR and high-temperature carbonization reactor

Structural and Gasification Kinetic Studies on Co-pyrolysis Chars of Coal and Biomass

Kinetic Studies of Char Gasification by Steam and CO2 in the Presence of H2 and CO

Determination of Char-CO<sub>2</sub> Gasification Rate Through Reaction Product

Some new insights into the effect of CO2 partial pressure on the non-isothermal gasification

Reaction kinetics and internal diffusion of Zhundong char gasification with CO2

Dong Shan Mei Jiao De Co2 Jia Ya Qi Hua Dong Li Xue Yan Jiu

Effect of Air Equivalence Ratio on the Characteristics of Biomass Partial Gasification for Syngas and Biochar Co-Production in the Fluidized Bed

Investigation on the Steam Gasification Mechanism of Different Chars Using Isotopic Tracing Method

Gasification Kinetics of Bituminous Coal Char in the Mixture of CO2, H2O, CO, and H2

Gas Emissions from Blends of Bituminous Coal and Biomass Chars under Different Pyrolysis Conditions

The Study Of Catalyzed Gasification Reaction Of Char By Co2

Gasification of the Char Residues with High Ash Content by Carbon Dioxide

Influence of Reactant Atmospheres and Temperature on Mechanism of Gasification of Coal Char Derived from Lignite

Experimental Studies on Gasification of the Shenmu Coal Char with CO2 at Elevated Pressures

Thermogravimetric Analysis of Coal Semi-Char Co-Firing with Straw in O2/CO2 Mixtures

Competition and Inhibition Effects During Coal Char Gasification in the Mixture of H2o and Co2

Gasification Characteristics of Different Rank Coals at H2O and CO2 Atmospheres

Some new insights into the kinetic compensation effect in different diffusion-controlled domain for char-CO2 gasification