Abstract:There is a vast amount of globally underutilized low-grade mine tailings and leach residues, including those from primary processing of gold. In this research, the target is to recover the remaining gold (10.9 g/t) from weathered refractory iron-rich residue that had previously been subject to autoclave oxidation, subsequent cyanidation in a conventional carbon-in-leach (CIL) circuit as well as storage at tailings area. Chloride leaching has been considered as one of the most promising cyanide-free gold leaching methods and it has shown positive outcomes in treating primary gold ores, concentrates, and flotation tailings. Therefore, in the current study, the iron-rich residue investigated was subjected to chloride leaching combined with simultaneous carbon adsorption. The investigated parameters included leaching time (2–8 h), chloride concentration ( [Cl − ] = 0.2–5 M), type and concentration of oxidant ( [Cu 2+ ]/[Fe 3+ ] = 0.1–1 M), as well as type and concentration of activated carbon (14–25 g/L), whereas S/L ratio (100 g/L), acidity ( pH = 1), and temperature (90 °C) were kept constant. Leaching results indicate that up to 40% of the remaining gold could still be recovered from the investigated residue with optimized chloride leaching. According to the results, the most important parameter for gold recovery was the leaching time. Moreover, of the studied oxidants, cupric ions were shown to contribute more to gold recovery when compared to ferric ions (35% vs. 24% at [Cu 2+ ]/[Fe 3+ ] = 0.1 M). Nevertheless, an increase of cupric concentration from 0.1 M (low-concentrated) to 0.5 M, resulted in only a slight increase in gold recovery (from 36% to 40%), whereas no further improvement in gold recovery was achieved with a 1 M cupric concentration. Two studied activated carbon products showed equal effectiveness in gold adsorption. In-situ carbon adsorption was shown to occur effectively in chloride media, as all dissolved gold could be detected in the activated carbon, and the concentration of remaining gold in the pregnant leach solution was minimal (< 0.02 mg/L). These findings indicate that low-concentrated chloride leaching of leach residues from industrial gold processes can allow an enhanced recovery of gold from previously mined and treated raw materials.

Bioleaching of Arsenic-Containing Refractory Gold Concentrate by Mixed Moderate Thermophiles in an Airlift Reactor

Simultaneous Ammonia and Nitrate Removal in an Airlift Reactor Using Poly(butylene Succinate) As Carbon Source and Biofilm Carrier.

Effects of Fe and cost-effective media composition on arsenopyrite bioleaching by Sulfobacillus thermosulfidooxidans

Sulfide Minerals Bio-Oxidation of a Low-Grade Refractory Gold Ore

Continuous Bioleaching of Arsenic-Containing Copper-Zinc Concentrate and Shift of Microbial Population under Various Conditions

Optimal parameters for bioleaching of realgar using Acidithiobacillus ferrooxidans under different growth conditions and mathematical analysis

Removal of Heavy Metals from MSWI Fly Ash Using Acidithiobacillus Strains: Effects of Substrate Concentration

Reagent Elution Combined with Positive Pressure Filtration: A Zero-Discharge Method for Cyanide Tailings Remediation

Bacterial Leaching of Discarded Copper Ores from Yongping, China

Bioleaching for the Removal of Arsenic from Mine Tailings by Psychrotolerant and Mesophilic Microbes at Markedly Continental Climate Temperatures

Novel strategy for reusing agricultural mulch film residual by iron modification for arsenic removal in gold-smelting wastewater

Integrated bio-oxidation and adsorptive filtration reactor for removal of arsenic from wastewater

Study on the role of microbial metabolites in in-situ noncontact bioleaching of ion-adsorption rare earth ore

Rapid gold cyanidation from a sulfur-high and arsenic-high micro-fine concentrate via facile two-stage roasting pre-treatment

Biofilm for leaching precious metals from waste printed circuit boards using biocyanidation technology

Continuous bioreactor leaching of nickel sulfide concentrates with moderately thermophilic bacteria and archaea

Bioleaching of Marmatite Flotation Concentrate with a Moderately Thermoacidophilic Iron-Oxidizing Bacterial Strain

Gold recovery from cyanidation residue by chloride leaching and carbon adsorption – Preliminary results from CICL process

Electrochemical behaviour of the oxidative dissolution of arsenopyrite catalysed by Ag+ in 9K culture medium

Acidithiobacillus ferrooxidans Leaching of Silica-Sulfide Gold Ores from May-Hibey Deposits, Tigray, Ethiopia

Bioleaching for metals removal from mine tailings flotation fractions