Abstract:The accumulated methane in goaf during coal mining may leak into the working face under the airflow influence, which is possibly causing disasters such as methane gas excessive at the working face and seriously threatening the mine safety. This paper first established a three-dimensional numerical model of the mining area under U-shaped ventilation, introducing the gas state equation, continuity equation, momentum equation, porosity evolution equation, and permeability evolution equation to simulate the airflow field and gas concentration field in the mining area under the natural state. The reliability of the numerical simulations is then verified by the measured air volumes at the working face. The areas in the mining area where gas is likely to accumulate are also delineated. Subsequently, the gas concentration field in goaf under the gas extraction state was theoretically simulated for different locations of large-diameter borehole. The maximum gas concentration in goaf and the gas concentration trend in the upper corner were analyzed in detail, and the critical borehole location (17.8 m from the working face) was determined as the optimum location for gas extraction from the upper corner. Finally, a gas extraction test was carried out on-site to evaluate the application effect. The results show that the measured airflow rate has a small error with the simulated results. The gas concentration in the area without gas extraction is high, with the gas concentration in the upper corner being over 1.2%, which is greater than the critical value of 0.5%. The maximum reduction in gas concentration was 43.9%, effectively reducing the gas concentration in the extraction area after employing a large borehole to extract methane gas. The gas concentration in the upper corner and the distance of the borehole from the working face are expressed as a positive exponential function. The field engineering results show that the implementation of the large borehole at a distance of less than 17.8 m from the working face can control the gas in the upper corner to less than 0.5%, effectively reducing the risk of gas in the upper corner. The numerical simulation work in this paper can provide some basic support for the design of an on-site borehole to extract gas from the mining void and reduce the gas hazard in coal mines.

Application of Quantification Theory I to Prediction of Gas Emission from No.5 Seam of Tangshan Mine

Study on gas emission prediction of working face based on GM (1, 1) model

Prediction of Gas Emissions in the Working Face Based on the Desorption Effects of Granular Coal: A Case Study

A calculation method of gas emission zone in a coal mine considering main controlling factors

Quantitative Analysis of Geological Factors Affecting Coal-Seam Gas Content

A software for calculating coal mine gas emission quantity based on the different-source forecast method

A dynamic model of coalbed methane emission from boreholes in front of excavation working face: numerical model and its application

Predicting the distribution of coalbed methane by ambient noise tomography with a dense seismic array

Study on Gas Migration Law of Mining Coal Seam under the Influence of Normal Fault

Real-Time Prediction of Oil-Type Gas Emissions in Coal-Oil-Gas Coexistence Mines

Influence of the roadway exposure time on the accuracy of gas content measurements in reconstructed and extended mines

Will greenhouse gas emissions increase with mining depth in coal mines? An analysis of gas occurrence under varying in-situ stress conditions

Time Series Prediction of Gas Emission in Coal Mining Face Based on Optimized Variational Mode Decomposition and SSA-LSTM

Numerical simulation and investigation of methane gas distribution and extraction in goaf with U-type ventilation of working face

Monitoring and Control Model for Coal Mine Gas and Coal Dust

Numerical modeling of gas extraction from coal seam combined with a dual-porosity model: Finite difference solution and multi-factor analysis

Numerical analysis and field tests of self-relief pressure zone ahead of mining workface: implications for methane extraction during underground mining

Optimizing Methane Control in Composite Goaf Areas: Insights from Multisource Emission Analysis and Numerical Modeling in the Tongxin Coal Mine

Study on the influence law of gangue filling structure on the gas emission in adjacent coal seams

Prediction Model of Spontaneous Combustion of Lignite in Zhalainuoer Mining Area

Quantitative evaluation of the indexes contribution to coal and gas outburst prediction based on machine learning