Abstract:The scope of this investigation aimed at obtaining and stabilizing bioactive products derived from Lycium barbarum seeds and peels, which were the byproducts in the processing of fruit juice. Zeaxanthin dipalmitate is a major carotenoid, comprising approximately 80% of the total carotenoid content in the seeds and peels. The method of obtainment was supercritical fluid CO2 extraction, studying different parameters that affect the oil yield and content of zeaxanthin dipalmitate. The optimized protocol to enact successful supercritical fluid CO2 extraction included optimum extraction pressure of 250 bar, temperature at 60 °C over a time span of 2.0 h, and a CO2 flow of 30 g/min, together with the use of a cosolvent (2% ethanol). The yields of oil and zeaxanthin dipalmitate under these optimal conditions were 17 g/100 g and 0.08 g/100 g, respectively. The unsaturated fatty acids were primarily linoleic acid (C18:2), oleic acid (C18:1), and γ-linolenic acid (C18:3), with their contents being as high as 91.85 ± 0.27% of the total fatty acids. The extract was a red-colored oil that was consequently microencapsulated through spray-drying with octenylsuccinate starch, gum arabic, and maltodextrin (13.5:7.5:3, w/w) as wall materials to circumvent lipid disintegration during storage and add to fruit juice in a dissolved form. The mass ratio of core material and wall material was 4:1. These materials exhibited the highest microencapsulation efficiency (92.83 ± 0.13%), with a moisture content of 1.98 ± 0.05% and solubility of 66.22 ± 0.24%. The peroxide content level within the microencapsulated zeaxanthin dipalmitate-rich oil remained at one part per eight in comparison to the unencapsulated oil, following fast-tracked oxidation at 60 °C for 6 weeks. This indicated the potential oxidation stability properties of microcapsule powders. Consequently, this microencapsulated powder has good prospects for development, and can be utilized for a vast spectrum of consumer health and beauty products.

RESEARCH OF EXTRACTION CATOTENOIDS FROM LYCIUM BARBARUM

Extraction Optimization and Antioxidant Activity for Carotenoid in Lycium Barbarum L.

Supercritical CO2 Cell Breaking Extraction of Lycium Barbarum Seed Oil and Determination of Its Chemical Composition by HPLC/APCI/MS and Antioxidant Activity

Characterization of Carotenoids in Lycium Barbarum Fruit by Using UPC2-PDA-Q-TOF-MSE Couple with Deep Eutectic Solvents Extraction and Evaluation of Their 5Α-Reductase Inhibitory Activity

Studies on the Extraction Technology of Pigment from Lycium

Development of an effective method based upon second-order overlapping repeated sample injections for isolation of carotenoids from Lycium barbarum L. fruits with elution-extrusion counter-current chromatography

Research on the Ultrasonic Extracting Techniques of Β-Carotene

Study of Extraction Conditions on the Carotenoid Produced from Cordyceps Militaris

Research on technological process of two-pot countercurrent extraction of hydroxysafflor yellow A

Supercritical Fluid CO2 Extraction and Microcapsule Preparation of Lycium barbarum Residue Oil Rich in Zeaxanthin Dipalmitate

Study on Extraction Processes of Lycium Barbarrum Polysaccharides

Study on the Extraction Condition of the Total Flavonoid from Lycium barbarum L.

Optimization of an Extraction and Purification Method of Total Flavonoids from Lycium Barbarum Leaves

Studies on the Extraction of Lycopene from Tomato

Extraction of Β-Carotene in Red Yeast Cells with Supercritical Carbon Dioxide Technology

Extracting Study on Pigment of Fructus Lycii

Extraction technology of chlorogenic acid from lycium

Study on the extraction process of flavonoids from lycium barbarum L. leaves

Technical Study and Comparison of Total Flavonoids Extracted in Lycium barbarum Leaves of Different Picked Time by Ultrasonography

Extraction and Antioxidant Activity of Carotenoids from Broccoli

Study on the Extraction Technology of Carotenoid from Rapeseed