Abstract:Ethanol production from energy crops which are renewable resources has gotten more and more attentions because of the energy crisis and environmental pollution. Sweetsorghum is considered as the most promising energy crop for the production of ethanol. Sweetsorghum stem is usually used to ferment ethanol, one of which is the liquid-state fermentation with the juice of sorghum stem. But a lot of bagasse of sorghum stem is discarded as wastes. The bagasse can be used as the supplemental materials of the fermentation of the juice. So it is absolutely necessary to study on the optimization of ethanol production with the bagasse and juice of the sorghum stem by simultaneous saccharification and fermentation (SSF). The response surface is an effective method to optimize the operating parameters of the SSF for the maximum ethanol yield. In this study, the Plackett-burman design was adopted to select the significant factors from 8 variables which influenced the ethanol yield and its concentration. The results indicated the ethanol yield and concentration were mainly influenced by the fermentation temperature, the amount of cellulase and the ratio of sorghum stem bagasse to its juice (P<0.05). And the other 5 variables which were not significant were remained to be the center level: the pH value was 5.5, the inoculation ratio was 0.2%, the amount of (NH4)2SO4 was 5 g/L, the fermentation time was 60 h, and the amount of uracil was 1 g/L. Based on the results of the selection, the steepest ascent experiment was conducted to determine the center point and the step size. The center point of the fermentation temperature was 37℃ and its step size was 3℃. The center point of the amount of cellulase was 20 FBU/30 CBU and its step size was 5 FBU/CBU. The center point of the ratio of bagasse to its juice was 7% and its step size was 1.5%. Then we adopted the Box-Behnken design and response surface analysis method to optimize the levels of these 3 significant factors, and the regression and the optimal levels of these significant factors were as follows: the regression model was very significant (P<0.0001,R2=0.9987, Adj.R2=0.9971 andCV=0.0099), which indicated that the model was reliable, and therefore, the regression model could be used for the theoretical prediction of the SSF for juice and bagasse of sweet sorghum stem; the fermentation temperature was 36.58℃, the amount of cellulase was 23.5 FBU/35.25 CBU, the ratio of bagasse to juice of sorghum stem was 8.2%, the maximum theoretical yield of ethanol predicted was 89.2%, and the ethanol concentration was 31.829 g/L. The interactive effects were analyzed by response surface analysis. The interactive effect of the fermentation temperature and the amount of cellulase was very significant (P<0.0001); the interactive effect of the amount of cellulase and the ratio of bagasse to juice was very significant (P<0.001); the interactive effect of the fermentation temperature and the ratio of bagasse to juice was not significant (P=0.2946). Under the optimal conditions, the model was proved to be valid by the verification test with 3 repeated tests, and the ethanol yield was 88.98% which was very close to the maximum yield (89.2%). The ethanol concentration was 31.78 g/L, which was very close to theoretical prediction value (31.829 g/L). The results of this optimal technology will provide a reference for the ethanol production technology by simultaneous saccharification and fermentation method for sweet sorghum stem.

Application Of Simultaneous Saccharification And Fermentation (Ssf) From Viscosity Reducing Of Raw Sweet Potato For Bioethanol Production At Laboratory, Pilot And Industrial Scales

Simultaneous Saccharification and Fermentation of Sweet Potato Powder for the Production of Ethanol under Conditions of Very High Gravity

Rapid Ethanol Production from Fresh Sweet Potato

Fermentation Potentials of Zymomonas Mobilis and Its Application in Ethanol Production from Low-Cost Raw Sweet Potato

Very High Gravity Fermentation Using Sweet Potato for Fuel Ethanol Production

Very High Gravity Fermentation of Ethanol with Fresh Sweet Potato

Potential utilization of waste sweetpotato vines hydrolysate as a new source for single cell oils production by Trichosporon fermentans.

One-step enzymatic hydrolysis of sweet potato residue after gelatinization for bioethanol production by Saccharomyces cerevisiae

Agro-industrial Waste Recycling by Trichosporon Fermentans: Conversion of Waste Sweetpotato Vines Alone into Lipid

SUBSTRATE INHIBITION REGULATED BY GLUCOAMYLASE DOSAGES IN SSF OF VHG SWEET POTATO MASH FOR ETHANOL PRODUCTION USING SACCHAROMYCES CEREVISIAE

Low Viscosity and Rapid Saccharification Pretreatment of Fresh Sweet Potato for Ethanol Production

Effects of Glucose Releasing Rate on Cell Growth and Performance of Simultaneous Saccharification and Fermentation (ssf) in Sweet Potato Medium for Fuel Ethanol Production Using Saccharomyces Cerevisiae

Mechanism for the Disparity of the Lipid Production by Trichosporon Fermentans Grown on Different Sweetpotato Vines Hydrolysates

Production of Bio Ethanol from Waste Potatoes

Ethanol Production from Steam-Pretreated Sweet Sorghum Bagasse with High Substrate Consistency Enzymatic Hydrolysis

Construction of an amylolytic Saccharomyces cerevisiae strain with high copies of α-amylase and glucoamylase genes integration for bioethanol production from sweet potato residue

FERMENTATION PROMOTION BY ALGAL NITROGEN SOURCE FEEDING IN FUEL ETHANOL PRODUCTION FROM SWEET POTATO MASH

Research on Fermentation of Acetone-Butanol-Ethanol with Sweet Potato As Raw Material

Bioethanol Production from Sweet Sorghum Stalk Juice with Immobilized Yeast

Ethanol Production from Sugarcane Bagasse by Fed‐batch Simultaneous Saccharification and Fermentation at High Solids Loading

Optimization of Ethanol Production from Bagasse and Juice of Sweet Sorghum Stem by Simultaneous Saccharification and Fermentation