Abstract:A novel adsorbent was obtained by using a typical solid waste electrolytic manganese residue (EMR) and a green material chitosan (CS) for the Cr(VI) removal from the aqueous environment. The tagged mineral phases and elements in the EMR were successfully detected in the synthesized composites according to the XRD and SEM-EDS results. Furthermore, the characteristic peak of metal and hydroxyl group binding appeared at 779 cm −1 , and the Si-O bending vibration at 454 cm −1 in the FT-IR pattern of the synthesized composites indicating the functional Fe and Mn hydroxyl groups and the silicates in EMR were all successfully grafted onto the CS. This obtained composite showed a high Cr adsorption capacity with a maximum adsorption capacity of 133.64 mg·g −1 , and the Cr(VI) removal rate could maintain a high level of 94.6 % after five adsorption–desorption cycles. Its adsorption isotherm matched with the Langmuir model, and the adsorption kinetics followed the pseudo-first-order model. According to the response surface CCD model, the optimal conditions for Cr(VI) removal were pH at 2, contact time at 53.0 min, and initial concentration at 100 mg·L -1 . For the removal mechanism, Cr(VI) anions could be easily electrostatic adsorbed by –NH 3 + , or chelated with the Fe and Mn oxides. Meanwhile, partial Cr(VI) (∼35.7 %) was reduced into Cr(III) by the abundant hydroxyl group of chitosan on the surface of the as-obtained materials, and then the free Cr(III) could be easily chelated with three chitosan monomers. This work opens up a novel and green methodology to modify chitosan and reuse the solid waste EMR.

Adsorption and recovery of Cr(vi) from wastewater by Chitosan–Urushiol composite nanofiber membrane

The Efficient Removal of Low Concentration Hexavalent Chromium Via Combining Charged Microporous Membrane and Micellar Adsorption Filtration

Chitosan Induced Synthesis of Few-Layer MoS2/Fe-doped Biochar and Its Dual Applications in Cr(VI) Removal

Insights into the performance and mechanism of Cr(VI) and U(VI) removal in water using innovative cross-linked chitosan adsorbent

Immobilization of in situ generated Fe 0 -nanoparticles in tripolyphosphate-crosslinking chitosan membranes for enhancing U(VI) adsorption

Immobilization of Carboxyl-Modified Multiwalled Carbon Nanotubes in Chitosan-Based Composite Membranes for U(VI) Sorption

Porous chitosan/biocarbon composite membrane as the electrode material for the electrosorption of uranium from aqueous solution

Sustainable Lignin-Reinforced Chitosan Membranes for Efficient Cr(VI) Water Remediation

Insight into a novel composite biosorbent by incorporating chitosan into electrolytic manganese residue for Cr(VI) removal from aqueous solutions

Preparation of a sulfonated coal@ZVI@chitosan-acrylic acid composite and study of its removal of groundwater Cr(VI)

Preparation of α-FeOOH loaded chitosan composite and its efficient removal for Cr(VI)

Facile synthesis of ZIF-8 incorporated electrospun PAN/PEI nanofibrous composite membrane for efficient Cr(VI) adsorption from water

Chitosan-based composite microspheres for treatment of hexavalent chromium and EBBR from aqueous solution

The Preparation of a Lignosulfonate/Chitosan–Graphene Oxide Hydrogel Biosorbent to Effectively Remove Cr(VI) from Wastewater: Adsorption Performance and Mechanisms

Recovery of Chromium(VI) Oxyanions from Aqueous Solution Using Cu(OH)2 and CuO Embedded Chitosan Adsorbents

Removal of Hexavalent Chromium(VI) from Wastewater Using Chitosan-Coated Iron Oxide Nanocomposite Membranes

Enhanced removal of hexavalent chromium from aqueous solution by functional polymer-wrapped gamma-alumina composite adsorbent

Magnetic red mud/chitosan based bionanocomposites for adsorption of Cr(VI) from aqueous solutions: synthesis, characterization and adsorption kinetics

EDAC-modified chitosan/imidazolium-polysulfone composite beads for removal of Cr(VI) from aqueous solution

Chitosan-Urushiol nanofiber membrane with enhanced acid resistance and broad-spectrum antibacterial activity

Simultaneous Detection and Adsorptive Removal of Cr(VI) Ions by Fluorescent Sulfur Quantum Dots Embedded in Chitosan Hydrogels