Abstract:Two novel solid acids of SO4 2-/ZnO and S2O8 2-/ZnO were prepared by impregnating H2SO4, (NH4)2S2O8 solution respectively on amorphous zinc oxide and calcining at 500-600°C, and then used as carriers to prepare Cu (I)/SO4 2-/ZnO and Cu (I)/S2O8 2-/ZnO catalysts via solid-state ion-exchange. The solid acids and catalysts were characterized by XRD, FTIR, TPD and TPR. It is observed that Zn3O (SO4)2 was formed during the preparation of the solid acids, and both of Lewis and Brønsted acid sites were formed on SO4 2-/ZnO and S2O8 2-/ZnO. NH3-TPD shows that both SO4 2-/ZnO and S2O8 2-/ZnO were very strong solid acids because the temperature of NH3 desorption peaks were above 543°C. It is suggested by molecule structure analysis that the form of acid sites is due to the strongly electronic inductive effect of SO4 2-, the bridge-coordination complex of ZnO and SO4 2- causes the formation of Brønsted and Lewis acid sites on the surface, but the chelate-coordination complex of ZnO and SO4 2- has not any contribution to acid sites. Prepared by solid-state ion-exchange with the solid acids and CuCl at high temperature in N2 follow, Cu (I)/SO4 2-/ZnO and Cu (I)/S2O8 2-/ZnO catalysts, in which Cu (I) was easy to be reduced, showed an excellent catalytic behavior in the oxidative carbonylation of methanol to dimethyl carbonate (DMC). Both of the catalysts showed high catalytic activity and selectivity: 98.13% selectivity of DMC based on methanol and 1.87 g/(g·h) space-time yield, respectively.

Preparation of Solid Superacid SO 4 2- /ZrO 2 and SO 4 2- /ZrO 2 -M x O y (M=Ce, Co, Mn, and Zn) and Its Application in Toluene Nitration

Preparation,characterization of nanosolid superacid TiO_2/SO_4~(2-) and regioselective nitration of toluene by catalysis

Investigation of Cu-Mn Catalytic Ozonation of Toluene: Crystal Phase, Intermediates and Mechanism

Catalytic Ozonation of Toluene over Spinel Cumn2o4: Influencing Factors, Reaction Mechanism and Pathways

Effect of ambient factors over spinel CuMn2O4 for toluene catalytic ozonation: Enhancement of the synergy and the generation of ROS

Promoting the Catalytic Ozonation of Toluene by Introducing SO 4 2- into the α-MnO 2 /ZSM-5 Catalyst to Tune Both Oxygen Vacancies and Acid Sites

Studies on n-butane isomerization reaction on solid oxide super acid Pt-SO4 2- /ZrO2-Al2O3 catalysts

A Novel Way to Prepare γ-Al2O3 Supported SO4 2-/ZrO2 Solid Superacid Catalysts for n-Butane Isomerization

A Novel Way To Prepare Gamma-Al2o3 Supported So42-/Zro2 Solid Superacid Catalysts For N-Butane Isomerization

Multicomponent Co-Zr-P-W-O Immobilized Zeolites Toward Solvent-Free Oxidation of Toluene to Benzaldehyde

Preparation and properties of ultrafine SO4 2- /ZrO2 superacid catalysts

Preparation of Fibrous SO42-/ZrO2-Nio Solid Acid Catalyst, Characterization and its Catalytic Properties

Studies on MCM-41 Supported SO4 2-/ZrO2 Solid Superacid Catalysts

Adsorption and Catalytic Ozonation of Toluene on Mn/ZSM-5 at Low Temperature

Preparation of Co<sub>3</sub>O<sub>4</sub>Catalysts by a Solid-state Reaction for Total Oxidation of Toluene

Preparation of Fibrous SO<sub>4</sub><sup>2-</sup>/ZrO<sub>2</sub>-Nio Solid Acid Catalyst, Characterization and Its Catalytic Properties

Highly Selective Oxidation of Methanol to Dimethoxymethane over So42-/V2o5-Zro2

Preparation and characterization of Cu(I)/SO42-/ZnO and Cu(I)/S2O82-/ZnO catalysts

Purification of Aromatics over a Promising SO42-/ZrO2 Catalyst

Preparation and characterization of Cu (I)/SO4 2-/ZnO and Cu (I)/S2O8 2-/ZnO catalysts

Preparation of Co_3O_4 Catalysts by a Solid-state Reaction for Total Oxidation of Toluene