Abstract:Combinations of nanoparticles and surfactants have been widely employed in many industrial processes, i.e., boiling and condensation in heat transfer and hydraulic fracturing in shale oil and gas production, etc. However, the underlying mechanism for various phenomena resulting from the addition of nanoparticles into the surfactant solutions is still unclear. For instance, there are contradictory conclusions from the literature regarding the variations of surface tension upon the addition of nanoparticles into surfactant solutions. In this work, the dominating factors determining if the surface activity of the surfactant solution will increase or conversely decrease when adding certain kinds of nanoparticles have been investigated. Two typical hydrophilic nanoparticles, SiO2 and TiO2 with anionic or cationic surfactants, respectively, have been considered. The surface tension has been measured in a wide range of nanoparticle and surfactant concentrations. It was found that the surface tension of the ionic surfactant solution can be further reduced only if nanoparticles of the same charge were added. For instance, a system containing 0.25 CMC SDS and 1 wt% SiO2 behaves similar to a 0.34 CMC SDS-only solution. Interestingly, the observed synergistic effect is found to be more significant if the surfactant concentration is much lower than its CMC for a given nanoparticle content. Moreover, the effect is perfectly reversible. When the nanoparticles were separated from the system, the surface tension values recovered fully to that of the pure surfactants. If nanoparticles of opposite charge were added, however, the surface tension of the surfactant solution increased. Zeta potential measurement and centrifugal treatment have been employed to reveal the interplay between nanoparticles and surfactants and the adsorption behavior of their assemblies at the liquid/air interface. Based on the experimental outcomes, a possible physical mechanism was proposed. It was concluded that the electrostatic repulsion between surfactant molecules and nanoparticles should be the dominant factor responsible for the observed reversible synergistic effect. Our study is expected to contribute to a better understanding of the interfacial phenomenon in nanoparticle-surfactant complex systems.

Direct observation of nanoparticle-surfactant assembly and jamming at the water-oil interface

Electrostatic‐Driven Dynamic Jamming of 2D Nanoparticles at Interfaces for Controlled Molecular Diffusion

Interfacial Assembly and Jamming of Soft Nanoparticle Surfactants into Colloidosomes and Structured Liquids

Visualizing Interfacial Jamming Using an Aggregation‐Induced‐Emission Molecular Reporter

Molecular Simulation of Surfactant Displacement of Residual Oil in Nanopores: Formation of Water Channels and Electrostatic Interaction

Direct nanoscopic imaging of the hydrated nanoparticle–ligand interface

Molecular dynamics study of nanoparticles and non-ionic surfactant at an oil–water interface

Direct Observation of Nanoparticle Self-Assembly Dynamics at the Water−Air Interface Using Differential Interference Contrast Microscopy

Self-Regulated Nanoparticle Assembly at Liquid/Liquid Interfaces: A Route to Adaptive Structuring of Liquids

Self-assembly of nanoparticles and surfactant molecules at the gas-liquid interface

Insights into the Complex Interaction Between Hydrophilic Nanoparticles and Ionic Surfactants at the Liquid/air Interface.

In situ, nonlinear optical probe of surfactant adsorption on the surface of microparticles in colloids

Observation of Electrostatically Driven Surface Adsorption in Mixed Surfactant Systems

Fluorescence in Situ Observation of the Interfacial Dynamics and Adhesion Behaviors of Water and Oil Droplets in A Confined Geometry

Mechanism of Biosurfactant Adsorption to Oil/water Interfaces from Millisecond Scale Tensiometry Measurements

Direct measurements of the effects of salt and surfactant on interaction forces between colloidal particles at water-oil interfaces

Self-Assembly of Nanomaterials at Fluid Interfaces

Retardation of Droplet Transport in Confined Microchannel by Interfacial Jamming of Nanoparticles

Nanoparticle surfactants for kinetically arrested photoactive assemblies to track light-induced electron transfer

Effect of Nanoparticle Surfactants on Droplet Formation in a Flow-Focusing Microchannel

Interfacial Assembly of Nanoparticles with Fluorous-Tagged Organic Molecules